Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

Protoplast isolation and regeneration from Hecatonema terminale (Ectocarpales, Phaeophyceae) using a simple mixture of commercial enzymes

Optimization of protoplast isolation and subsequent regeneration from the economically important brown alga Ecklonia cava using response surface methodology

Isolation and regeneration of protoplasts from<i>Penicillium digitatum</i>

Isolation and regeneration of Metarhizium anisopliae protoplasts and their hydroxylase activity

High efficiency of protoplast preparation for artificially cultured Ulva prolifera (Ulvophyceae, Chlorophyta)

Isolation, culture of Platycodon grandiflorus protoplasts: factors affecting protoplast yield, cell division, and micro-callus formation

Research on the Preparation and Regeneration of Protoplast from High-concentration Mash Resistant Saccharomyces Cerevisia

Optimization of protoplast regeneration in the model plant Arabidopsis thaliana

A Effective Protocol for King Grass Reyan No.4 Protoplasts Preparation of King Grass Reyan No.4

High Frequency Plant Regeneration from Protoplasts in Cotton Via Somatic Embryogenesis

Enzymes Produced by Biomass-Degrading Bacteria Can Efficiently Hydrolyze Algal Cell Walls and Facilitate Lipid Extraction

An Efficient and Universal Protoplast Isolation Protocol Suitable for Transient Gene Expression Analysis and Single-Cell RNA Sequencing

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Enhancing Protoplast Isolation and Early Cell Division from Cannabis sativa Callus Cultures via Phenylpropanoid Inhibition

Optimization of Protoplast Preparation and Establishment of Genetic Transformation System of an Arctic-Derived Fungus Eutypella sp.

Enhanced whole-cell biotransformation of 3-chloropropiophenone into 1-phenyl-1-propanone by hydrogel entrapped Chlorella emersonii (211.8b)

Factors Analysis in Protoplast Isolation and Regeneration from A Chalkbrood Fungus, Ascosphaera Apis

Protoplasts from Agrobacterium rhizogenes-transformed cell line of Medicago sativa L. regenerated to hairy roots

Efficient utilization of brown algae for the production of Polyhydroxybutyrate (PHB) by using an enzyme complex immobilized on Ralstonia eutropha

Protoplast Preparation for Algal Single-Cell Omics Sequencing