Abstract:Cheese whey (CW) is a nutrient deficient dairy effluent, which requires external nutrient supplementation for aerobic treatment. CW, supplemented with ammonia, can be treated using aerobic granular sludge (AGS) in a sequencing batch reactor (SBR). AGS are aggregates of microbial origin that do not coagulate under reduced hydrodynamic shear and settle significantly faster than activated sludge flocs. However, granular instability, slow granulation start-up, high energy consumption and CO 2 emission have been reported as the main limitations in bacterial AGS-SBR. Algal-bacterial granular systems have shown be an innovative alternative to improve these limitations. Unfortunately, algal-bacterial granular systems for the treatment of wastewaters with higher organic loads such as CW have been poorly studied. In this study, an algal-bacterial granular system implemented in a SBR (SBR AB ) for the aerobic treatment of ammonia-supplemented CW wastewaters was investigated and compared with a bacterial granular reactor (SBR B ). Mass balances were used to estimate carbon and nitrogen (N) assimilation, nitrification and denitrification in both set-ups. SBR B exhibited COD and ammonia removal of 100% and 94% respectively, high nitrification (89%) and simultaneous nitrification-denitrification (SND) of 23% leading to an inorganic N removal of 30%. The efficient algal–bacterial symbiosis in granular systems completely removed COD and ammonia (100%) present in the dairy wastewater. SBR AB microalgae growth could reduce about 20% of the CO 2 emissions produced by bacterial oxidation of organic compounds according to estimates based on synthesis reactions of bacterial and algal biomass, in which the amount of assimilated N determined by mass balance was taken into account. A lower nitrification (75%) and minor loss of N by denitrifying activity (<5% Ng, SND 2%) was also encountered in SBR AB as a result of its higher biomass production, which could be used for the generation of value-added products such as biofertilizers and biostimulants.

Application of sequencing batch biofilm reactor (SBBR) in dairy wastewater treatment

Performance of Novel Sponge Biocarrier in MBBR Treating Recirculating Aquaculture Systems Wastewater: Microbial Community and Kinetic Study.

Treatment of dairy effluents in an aerobic granular sludge sequencing batch reactor

Optimizing sequencing batch reactor (SBR) reactor operation for treatment of dairy wastewater with aerobic granular sludge

Study on SBBR process for simulation swine wastewater treatment

Treatment of high-strength sewage by textile fibers-based sequencing batch biofilm reactor for simultaneous removal of organics and nutrients

Carbon and nitrogen removal from a wastewater of an industrial dairy laboratory with a coupled anaerobic filter-sequencing batch reactor system.

Simultaneous Removal of Organic Matter and Nutrients from High Strength Organic Wastewater Using Sequencing Batch Reactor (SBR)

[Performance Improvement of Sequencing Batch Reactor (SBR) Treating Digested Piggery Wastewater by Addition of Raw Wastewater].

Improvement in Post-Treatment of Digested Swine Wastewater

Evaluating the potential of a new reactor configuration to enhance simultaneous organic matter and nitrogen removal in dairy wastewater treatment

Assessment of the performance of a symbiotic microalgal-bacterial granular sludge reactor for the removal of nitrogen and organic carbon from dairy wastewater

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

Organic and nutrient removal for domestic wastewater treatment using bench-scale sequencing batch reactor

Simultaneous Removal of Nitrogen and Phosphorus from Swine Wastewater in a Sequencing Batch Biofilm Reactor

A Reformed SBR Technology Integrated with Two‐step Feeding and Low‐intensity Aeration for Swine Wastewater Treatment

Optimization of Simultaneous Nutrients and Chemical Oxygen Demand Removal from Anaerobically Digested Liquid Dairy Manure in a Two-Step Fed Sequencing Batch Reactor System Using Taguchi Method and Grey Relational Analysis

A Comparison of Biosolids Production and System Efficiency between Activated Sludge, Moving Bed Biofilm Reactor, and Sequencing Batch Moving Bed Biofilm Reactor in the Dairy Wastewater Treatment

Design of Sequencing Batch Reactor (SBR) Treatment Plant for Abattoir Wastewater (A Case of Apa Mmini Stream)

To Optimize Sequencing Batch Reactor (SBR) and Monitor Aerobic Granular Sludge (AGS) Development for Domestic Wastewater Treatment

Anaerobic Digestion and Post-Treatment of Swine Wastewater Using IC–SBR Process with Bypass of Raw Wastewater