Abstract:The performance of a pump as a turbine on an oil transmission line was investigated experimentally and numerically. An external gear pump was employed regarding the high working pressure of the system, maximally 80 bar, as an actuator of the centrifugal pump. It was observed that the system had an optimal point. This issue enhanced the system's efficiency by 19% as the mass flow rate increased by 1.9 L/s in the outlet pressure of 80 bar. Replacing control valves in the inlet lines of oil transmission stations with hydropower plants can be a logical solution to convert energy losses into useful power. In this regard, this paper carried out an experimental and numerical investigation to study the feasibility of applying a pump as turbine in a hydropower system and its performance on the oil transmission lines. An experimental platform, comprising a tank, hydropower, centrifugal pump, electromotor, and measuring instruments, was constructed. An external gear pump was employed regarding the high working pressure of the system, maximally 80 bar, as an actuator of the centrifugal pump. By comparing the efficiency of the electropump with the hydropower‐driven pump, it was observed that maximum efficiency, approximately 20.6%, occurred when the pump reached its best efficiency point. Furthermore, based on experiments on hydropower‐driven pump under different inlet pressures, an optimal point was observed for the system. This issue enhanced the system's efficiency by 19% as the flow rate increased by 1.9 L/s in the inlet pressure of 80 bar. According to the results, as the flow rate increases, there is a descending trend in outlet pressure. Besides this, there is an optimum condition for the maximum efficiency of hydropower plants and this crucial point should be determined by experimental or numerical studies to reach maximum performance. Furthermore, extracted values of power from the computational fluid dynamics model were compared with the experiments with less than 8% error in most cases. Therefore, a correlation was introduced for the prediction of power based on effective parameters of outlet pressure and volumetric flow rate for the off‐design condition in each inlet pressure with roughly 2% error.

Numerical Simulation and Experimental Research on Oil Mist Overflowing for a Giant Hydropower Generator

Research on Oil Mist Leakage of Bearing in Hydropower Station: A Review

The Numerical Simulation of Extinguish Pool Fire by Water Mist

Numerical Simulation and Optimization of Internal Flow Field in the High Pressure Coal Conveying Pump Based on the Dynamic Mesh

Experimental Study on the Cavitation Characteristics of an Oil Jet Pump with Multiple Nozzles for the Lubrication System in a Steam Turbine

Simulation Study on Influence of Installation Height of Mist Eliminator on Liquid Holdup of Flue Gas in Desulfurization Tower

Numerical Simulation And Experimental Study Of The Pressure Fluctuation In Water Turbines

Numerical investigation on performance of moisture separator by Lagrangian-Eulerian strategy: Physical mechanisms, theoretical models, and advanced algorithms

Numerical Investigation on Droplet Collision Phenomena in Moisture Separators Using Population Balance Model under Lagrangian Framework

NUMERICAL SIMULATION OF SPONTANEOUSLY CONDENSING FLOWS IN A PLANE TURBINE CASCADE

Numerical and Experimental Investigation of Splashing Oil Flow in a Hypoid Gearbox

Experimental research and turbulent flow simulation of the updraft free-exit-flow hydropower turbine system

Study Of The Numerical Solving Methods Of The Motion Model Of Polydispersed Droplets

Development and Validation of a Two-Fluid Three-Field Model for the Vertical Upward Flow

An experimental and numerical investigation into using hydropower plant on oil transmission lines

Numerical Study on the Influence of Mist-Air Mixtures on Axial Compressor Performance

Overflow Energy Loss Recovery System Based on Hydraulic Motor-Electric Generator

Numerical Investigation on Performance of Moisture Separator: Experimental Validation, Applications and New Findings

Numerical Simulation and Experiment on the Active Hydrocyclone Oil-Water Separation in Deepwater

Three-Dimensional Numerical Modeling of Large-Scale Free Surface Flows with Heat and Contaminant Transfer in Reservoirs

Numerical simulation of free-surface flow in updraft-free-exit-flow hydropower turbine