Abstract:In this paper, a three-phase, two stage, bidirectional off board plug-in Electric Vehicle (PEV) charger controller has been designed and implemented in real time. The proposed PEV charger is able to work in all four quadrants in active-reactivepower plane. Generally, power electronics converters are controlled by PI regulators in d-q reference frame, where the signals to be regulated are inherently DC in nature. These controllers are implemented in two loops i.e., Slow (outer) control loop and fast (inner) control loop. Setting the gains of outer loops are little bit easier in comparison to fast acting inner loops besides the involvement of decoupling terms to have independent operation of active and reactive current components. Therefore, a repetitive controller (RC) is designed to regulate the inner sinusoidal reference current having both active-reactive components as per the control requirement without involving any decoupling terms. The RC is well known for their ability to track periodic signal and inherently based on internal model control theory. However, the major problem with RC is its sensitivity due to which it provides high gains at all frequencies levels. Therefore, in proposed controller the sensitivity of RC is modified by squaring it. This results the deep notches at higher frequency levels This approach is found to be very much suitable for the compensation of reactive power and load current harmonics. This also helps to exclude unwanted frequencies which results reduction in THD level. Therefore, the main contribution of this paper is adapting such robust EV charger controller for harmonic compensation. Moreover, from the implementation, it is found that the conventional RC is capable to compensate load current harmonic to some extent but it takes around 140 μs computational time. However, the proposed RC takes around 100 μs computational time, this results the grid current purely sinusoidal. The MATLAB/Simulink environment has been used to simulate proposed PEV charger controller, further it has been verified on scaled down experimental prototype.

Processor in the Loop for Testing Series Motor Four Quadrants Drive Direct Current Chopper for Series Motor Driven Electric Car

Close Loop Feedback Direct Current Control in Driving Mode of a Four Quadarnts Drive Direct Current Chopper for Electric Vehicle Traction Controlled Using Fuzzy Logic

Mechatronic model and simulation of four-wheel Mecanum vehicle driven by BLDC

Emulation and Testing for Automotive Propulsion Drive Using Two Cascaded Inverters

Digital Proportional Integral Derivative (PID) Controller for Closed-Loop Direct Current Control of an Electric Vehicle Traction Tuned Using Pole Placement

Processor-in-the-Loop Simulation of an Interleaved Buck Converter With MATLAB/Simulink

Cohesive DS-PID and FQL Control Mechanisms to Enhance the Performance of the Electric Vehicle System

Power Electronic Load System for Motor Drivers Testing Considering Motor Faulty Status Simulation

High-Power-Factor Control Of Ipmsm Drive System With Small Dc-Link Capacitor

Comparative Performance Evaluation of Hall Effect Sensorless Control Options in Permanent Magnet Brushless DC Motor Drives

Performance analysis and enhancement of brain emotion-based intelligent controller and its impact on PMBLDC motor drive for electric vehicle applications

An Investigation into the Use of Hardware-in-the-loop Simulation Testing for Brushless DC Motor Drive of Hybrid Electric Vehicle

Simulation based study of IM control strategies for EV/HEV applications

A Novel Approach to Evaluating Battery Charger Controller Design with Nonlinear PID Controller in an Extendable CHIL Setup

A Research on the Control Algorithm for Brushless Motor in Four-wheel Hub Motor Drive Electric Vehicle

Bi-directional DC-AC using BLDC motor for electric and hybrid electric vehicles applications with reduced number of switches

Brain Emotional Learning and Adaptive Model Predictive Controller for Induction Motor Drive: A New Cascaded Vector Control Topology

Modified repetitive control design for two stage off board Electric Vehicle charger

Four-Quadrant Drive Control and Signal Conditioning of Dc Load Motor for Permanent Magnetic Machine Testing

Research on motor driving and vehicle charging integrated system

Field-Oriented Control of Five-Phase Induction Motor Fed From Space Vector Modulated Matrix Converter