Abstract:The dioxins (DXN) are a set of pollutants encompass polychlorinated dibenzo-p-dioxin/dibenzofuran (PCDD/F), their emissions from municipal waste incineration processes (MSWI) are normally detected under steady operating conditions. However, limited studies have focused on the PCDD/F emission characteristics under a complete maintenance operating period (CMOP), which includes shut-down, cooling, maintenance, heating, startup, and normal operations. In this article, the shutdown process (SDP) starts from the normal operation, followed by shutdown, and then cooling; while the startup process (SUP) commences from heating, followed by startup, and then normal operation. The detection and analysis were conducted at the SDP and SUP stages. The PCDD/F mass and total toxic equivalent quantity (TEQ) concentrations were measured in the flue gas and bag filter fly ash (BF-FA) during a CMOP of Beijing MSWI plant. The highest PCDD/F concentrations in the flue gas were found in the "cooling" and "startup" phases; in the FA, this condition occurred in the "startup" phase. Further, the results show that the most heightened concentrations were observed for 5–6 chlorinated PCDF and 4–5 chlorinated PCDD among the 17 PCDD/F congeners in most cases. More importantly, the air pollution control devices (APCDs) which include activated carbon, lime, and BF, have high removal efficiency for PCDD/F (especially PCDD) during the "startup" phase. APCDs also easily release a considerable amount of PCDD/F because of the memory effect, which emits more PCDD/F at the "shutdown" phase than at the "startup" one. Besides, the annual PCDD/F emission in the flue gas of the MSWI plant was estimated to be 67.72 mg I-TEQ, of which the emission accounts for approx. 20% during the CMOP. Moreover, the experiment shows that the PCDD/F emissions of the MSWI plant in Beijing under unsteady conditions are more miniature than those reported earlier in other areas.

Measurement of Dioxin Emissions from a Small-Scale Waste Incinerator in the Absence of Air Pollution Controls

Microsoft Word-Manuscript rev2

Polychlorinated Dibenzo- P -Dioxins and Dibenzofurans in Flue Gas Emissions from Municipal Solid Waste Incinerators in China

Emission Characteristics of Polychlorinated Dibenzo-p-dioxins and Dibenzofurans from the Co-combustion of Municipal Solid Waste in a Lab-Scale Drop-Tube Furnace

PCDD/Fs emissions in a large-scale hazardous waste incinerator under different operation conditions: Effective reduction strategies and an applicable correlation

Phase Distribution of PCDD/Fs in Flue Gas from Municipal Solid Waste Incinerator with Ultra-Low Emission Control in China.

Assessment of PCDD/Fs Emission during Industrial-Organic-Solid-Waste Incineration Process in a Fluidized-Bed Incinerator

Characteristics of PCDD/Fs in Flue Gas from MSWIs and HWIs: Emission Levels, Profiles and Environmental Influence

Reduction of Polychlorinated Dibenzo-p-dioxins and Dibenzofurans by Chemical Inhibition and Physisorption from a Municipal Solid Waste Incineration System

Emission Characteristics of PCDD/Fs in Stack Gas from Municipal Solid Waste Incineration Plants in Northern China

Fate of Dioxins in a Municipal Solid Waste Incinerator with State-of-the-art Air Pollution Control Devices in China.

Investigation on dioxins emission characteristic during complete maintenance operating period of municipal solid waste incineration

Suppression of Dioxins in Waste Incinerator Emissions by Recirculating So2

National and Provincial Dioxin Emissions from Municipal Solid Waste Incineration in China

Assessment of PCDD/Fs formation and emission characteristics at a municipal solid waste incinerator for one year

Effect of Different Air Pollution Control Devices on the Gas/solid-Phase Distribution of PCDD/F in a Full-Scale Municipal Solid Waste Incinerator.

Pcdd/F Emissions from Hazardous Waste Incinerators in China

Formation, migration, and removal mechanisms of PCDD/Fs throughout the temperature range (850°C–150°C) in a full-scale MSW incinerator: The invention of novel high-temperature PCDD/F sampling device

Levels and Profiles of Dioxins from Circulating Fluidised Bed Incineration

Concentrations, Profiles, And Sources Of Atmospheric Pcdd/Fs Near A Municipal Solid Waste Incinerator In Eastern China

Robust Online Monitoring System for PCDD/Fs in a Full-Scale MSWI by Deans Switch: Efficiently Separation and Purification