Reduction of Escherichia coli O157:H7 and naturally present microbes on fresh-cut lettuce using lactic acid and aqueous ozone

Jiayi Wang,Shan Wang,Yeting Sun,Chen Li,Yanru Li,Qi Zhang,Zhaoxia Wu

DOI: https://doi.org/10.1039/c9ra03544c

IF: 4.036

2019-01-01

RSC Advances

Abstract:Lactic acid plus aqueous ozone is an effective hurdle technology for fresh produce disinfection.

chemistry, multidisciplinary

What problem does this paper attempt to address?

Inactivation Mechanism of Escherichia Coli Induced by Slightly Acidic Electrolyzed Water.

Zhangying Ye,Shuo Wang,Tao Chen,Weishan Gao,Songming Zhu,Jinsong He,Zhiying Han

DOI: https://doi.org/10.1038/s41598-017-06716-9

IF: 4.6

2017-01-01

Scientific Reports

Abstract:Foodborne disease outbreak caused by food microbiological contamination is a serious public health problem. Slightly acidic electrolyzed water (SAEW), a new ultra-high effect and wide-spectrum disinfectant that is colourless, odourless, and harmless to humans and the environment, is directly used on food surfaces in Japan and America. However, the underlying inactivation mechanism remains unknown. In this study, biochemical and cellular changes were observed to investigate the bactericidal mechanism of SAEW against Escherichia coli (E. coli). The results indicated that SAEW with a pH of 6.40, an oxidation-reduction potential (ORP) of 910 mV, an available chlorine concentration (ACC) of 60 mg/L, and a volume ratio of 20:1, produced the most effective sterilization action. A fluorescence-based live-dead assay was further used to demonstrate the sterilized effect and the cell esterase activity damage caused by SAEW. During the observation period, within 10 min, the cell morphology changed, which was characterized by cell expansion, cell elongation and increased membrane permeability. Meanwhile, reactive oxygen substances (ROS) were released in the bacterial cells. E. coli inactivation and apoptosis induced by SAEW were observed. Our findings illustrate that the bactericidal effects of SAEW against E. coli occurred through cellular and biochemical mechanisms of cell necrosis and apoptosis.
Inactivation of Escherichia Coli O157:H7 and Salmonella and Native Microbiota on Fresh Strawberries by Antimicrobial Washing and Coating.

Mingming Guo,Tony Z. Jin,Joshua B. Gurtler,Xuetong Fan,Madhav P. Yadav

DOI: https://doi.org/10.4315/0362-028x.jfp-18-007

IF: 2.745

2018-01-01

Journal of Food Protection

Abstract:Antimicrobial washing (AW), antimicrobial coating (AC), and a combination of washing followed by coating (AW+AC) were evaluated for their ability to inactivate artificially inoculated foodborne pathogens and native microbiota on strawberries stored at 4°C. Strawberries were inoculated with a six-strain composite of Escherichia coli O157:H7 and Salmonella; treated by AW, AC, or AW+AC; and stored at 4°C for 3 weeks. The washing solution contained 90 ppm of peracetic acid, and the coating solution consisted of chitosan (1%, w/v), allyl isothiocyanate (1%, v/v), and corn-bio fiber gum (5%, w/v). The effectiveness of the antimicrobial treatments against E. coli O157:H7 and Salmonella pathogens and native microflora on strawberries and their impact on fruit quality (appearance, weight loss, color, and firmness) were determined. By the end of storage, pathogen populations on strawberries were 2.5 (AW+AC), 2.9 (AC), 3.8 (AW), and 4.2 log CFU for the positive (untreated) control. AW+AC treatments also inactivated the greatest population of native microflora, followed by the AC treatment alone. AW+AC treatments showed additional antimicrobial effectiveness against these two pathogens and native microflora. Both AW+AC and AC treatments preserved the color, texture, and appearance of strawberries throughout storage. The coating treatments (AW+AC and AC alone) further reduced the loss of moisture throughout storage. The AW treatment was the least effective in reducing populations of pathogens and native microflora and in maintaining the quality of strawberries throughout storage. This study demonstrates a method to improve the microbiological safety, shelf life, and quality of strawberries.
Antimicrobial Films and Coatings for Inactivation of Listeria Innocua on Ready-To-Eat Deli Turkey Meat

Mingming Guo,Tony Z. Jin,Luxin Wang,O. Joseph Scullen,Christopher H. Sommers

DOI: https://doi.org/10.1016/j.foodcont.2013.11.018

IF: 6

2014-01-01

Food Control

Abstract:Edible antimicrobial coating solutions incorporating chitosan, lauric arginate ester (LAE) and nisin were developed to reduce foodborne pathogen contamination on ready-to-eat (RTE) meats. RTE deli meat samples were directly coated with the solutions, or treated with solution-coated polylactic acid (PLA) films. The antimicrobial efficacy of the coatings and films against Listeria innocua inoculated onto the surface of RTE meat samples was investigated. Antimicrobial coatings with 1.94 mg/cm(2) of chitosan and 0.388 mg/cm(2) of LAE reduced L. innocua by ca. 4.5 log CFU/cm(2). Nisin (486 IU/cm(2)) showed less effectiveness than LAE (0.388 mg/cm(2)) and addition of nisin to the antimicrobial coatings or films containing LAE (0.388 mg/cm(2)) did not enhance the total antimicrobial effectiveness. Combining antimicrobial coatings or films with flash pasteurization (FP), which uses short burst of steam under pressure, further reduced L. innocua, achieving over a 5 log reduction. There was no significant difference in the effectiveness of antimicrobial films versus the coatings (p > 0.05). These data show the potential use of antimicrobial packaging alone, or in combination with FP, in preventing foodborne illness due to post-processing contamination of RTE meat products. Published by Elsevier Ltd.
Decontamination of Escherichia coli O157:H7 on fresh Romaine lettuce using a novel bacteriophage lysin

Siyue Xu,Edmondo Campisi,Jinquan Li,Vincent A Fischetti

DOI: https://doi.org/10.1016/j.ijfoodmicro.2021.109068

2021-03-02

Abstract:Raw vegetables are a key food for a healthy diet, but their increased consumption brings a higher risk for foodborne disease. Contamination of salad greens with Shiga toxin-producing Escherichia coli (STEC) O157:H7 has caused severe disease and important economic losses almost yearly in the United States over the last 10 years. To curb the risk of infections from contaminated produce, approaches based on bacterial virus - commonly known as bacteriophage or phage - have recently started to draw interest among other antimicrobial strategies. Phages enter bacterial cells to reproduce and cause cellular lysis to release their phage progeny at the end of their infection cycle. This lytic effect is caused by lysins, phage-encoded enzymes that have evolved to degrade the bacterial cell wall resulting in hypotonic lysis. When applied externally in their purified form, such enzymes are able to kill sensitive bacteria on contact in a similar way. Their unique bactericidal properties have made lysins effective antimicrobial agents in a variety of applications, from treating multidrug-resistant infections in humans to controlling bacterial contamination in several areas, including microbiological food safety. Here we describe a novel lysin, namely PlyEc2, with potent bactericidal activity against key gram-negative pathogens including E. coli, Salmonella, Shigella, Acinetobacter and Pseudomonas. PlyEc2 displayed high bactericidal activity against STEC to a concentration of 12.5 μg/ml under different pH conditions. This lysin was also able to reduce the bacterial titer of several pathogenic strains in vitro by more than 5 logarithmic units, resulting in complete sterilization. Importantly, PlyEc2 proved to be a powerful produce decontamination agent in its ability to clear 99.7% of contaminating STEC O157:H7 in our Romaine lettuce leaf model. PlyEc2 was also able to eradicate 99.8% of the bacteria contaminating the washing solution, drastically reducing the risk of cross-contamination during the washing process. A sensory evaluation panel found that treatment with PlyEc2 did not alter the visual and tactile quality of lettuce leaves compared to the untreated leaves. Our study is the first to describe a highly effective lysin treatment to control gram-negative pathogenic contamination on fresh lettuce without the addition of membrane destabilizing agents.
Sequential Treatment with Slightly Acidic Electrolyzed Water (SAEW) and UVC Light-Emitting Diodes (Uvc-Leds) for Decontamination of Salmonella Typhimurium on Lettuce

Rongwei Han,Xinyu Liao,Chunmei Ai,Tian Ding,Jun Wang

DOI: https://doi.org/10.1016/j.foodcont.2020.107738

IF: 6

2020-01-01

Food Control

Abstract:The present study investigates a small-scale system comprising a sequential treatment with slightly acidic electrolyzed water (SAEW) washing and UVC light-emitting diodes (LEDs) for the inactivation of Salmonella on lettuce. Lettuce was inoculated with a Salmonella cocktail to achieve a final concentration of 6.67 log(10) CFU/g. Alone treatment by SAEW washing (available chlorine concentration-ACC 20-80 ppm, 1-7 min) or UVC-LED irradiation (50-200 mu W/cm(2), 1-30 min) resulted in the reduction of 1-1.8 log(10) CFU/g Salmonella on lettuce. The sequential treatment with SAEW washing and UVC-LED significantly (p < 0.05) enhance the reduction of Salmonella on lettuce to 2.56-2.97 log(10) CFU/g. The results also revealed that the sequential treatment did not result in obvious compromise in the qualities (color, chlorophyll, and total soluble solid content) of lettuce. Therefore, the proposed sequential treatment of SAEW washing and UVC-LED in this study has the potential to assure the food safety of fresh produce.
Use of aqueous ozone rinsing to improve the disinfection efficacy and shorten the processing time of ultrasound-assisted washing of fresh produce

Yeting Sun,Zhaoxia Wu,Yangyang Zhang,Jiayi Wang

DOI: https://doi.org/10.1016/j.ultsonch.2022.105931

Abstract:In minimal processing industry, chlorine is widely used in the disinfection process and ultrasound (US) increases the disinfection efficacy of chlorine and reduces the cross-contamination incidence during washing. Tap water (TW), which has no disinfection effect, is generally used to rinse off sanitizer residues on the surface of disinfected fresh-cut vegetables. In this study, aqueous ozone (AO), a low-cost and residue-free sanitizer, was used to replace TW rinsing in combination with US (28 kHz)-chlorine (free chlorine [FC] at 10 ppm, a concentration recommended for industrial use) for the disinfection of fresh-cut lettuce as a model. US-chlorine (40 s) + 2.0 ppm AO (60 s) treatment resulted in browning spots on lettuce surface at the end of storage. In contrast, US-chlorine (40 s) + 1.0 ppm AO (60 s) did not lead to deterioration of the sensory quality (sensory crispness, color, and flavor) and a change in total color difference, and the activities of browning-related enzymes were significantly lower. Moreover, US-chlorine (40 s) + 1.0 ppm of AO (60 s) treatment led to significantly lower counts of Escherichia coli O157:H7, Salmonella Typhimurium, aerobic mesophilic (AMC), and molds and yeasts (M&Y) on days 0-7 than US-chlorine (60 s) + TW (60 s) and single 1.0 ppm AO (120 s) treatments, suggesting that AO provided an additional disinfection effect over TW, while reducing the overall processing time by 20 s. Cell membrane permeability analysis (alkaline phosphatase, protein, nucleotide, and adenosine triphosphate leakage) showed that the combination with 1.0 ppm AO caused more severe cell membrane damage in E. coli O157:H7 and S. Typhimurium, explaining the higher disinfection efficacy. 16S rRNA sequencing revealed that following US-chlorine (40 s) + 1.0 ppm of AO (60 s) treatment, Massilia and Acinetobacter had higher relative abundances (RAs) on day 7 than after US-chlorine (60 s) + TW (60 s) treatment, whereas the RAs of Escherichia-Shigella was significantly lower, indicating that the former treatment has a superior capacity in maintaining a stable microbial composition. This explains from an ecological point of view why US-chlorine (40 s) + 1.0 ppm of AO (60 s) led to the lowest AMC and M&Y counts during storage. The study results provide evidence that AO has potential as an alternative to TW rinsing to increase the disinfection efficacy of US-chlorine.
Use of Essential Oil Emulsions to Control Escherichia coli O157:H7 in the Postharvest Washing of Lettuce

Jessica Santos Pizzo,Raira Andrade Pelvine,Andre Luiz Biscaia Ribeiro da Silva,Jane Martha Graton Mikcha,Jesui Vergilio Visentainer,Camila Rodrigues

DOI: https://doi.org/10.3390/foods12132571

IF: 5.2

2023-07-02

Foods

Abstract:Essential oils (EOs) have strong antibacterial properties and can be potential sanitizers to reduce pathogen load and prevent cross-contamination during postharvest washing. The objective of this study was to investigate the efficacy of emulsions containing oregano (OR; Origanum vulgare) and winter savory (WS; Satureja montana) EOs at different concentrations (0.94 and 1.88 μL/mL) and storage times (0 h, 24 h, and 7 days), in reducing Escherichia coli O157:H7 on the surface of three types of lettuce (romaine, crisphead, and butterhead). The EO emulsions were compared with one no-rinse treatment and three rinse treatments using water, 200 ppm chlorine, and 80 ppm peroxyacetic acid (PAA), respectively, in a simulated washing system. The results showed that while the EO emulsions significantly reduced E. coli O157:H7 on crisphead lettuce over time, not all treatments were effective for romaine and butterhead lettuce. The mixture of OR and WS at concentrations of 0.94 and 1.88 μL/mL was found to be the most effective in reducing E. coli O157:H7 on inoculated lettuce, resulting in reductions of 3.52 and 3.41 log CFU/g, respectively. Furthermore, the PAA and the mixture of OR and WS at 1.88 μL/mL effectively limited bacterial cross-contamination close to the detection limit for all lettuce types during all storage times. These results suggest that OR and WS EOs could serve as potential alternatives to chemical sanitizers for postharvest lettuce washing.

food science & technology
Use of Acetic Acid to Partially Replace Lactic Acid for Decontamination against Escherichia coli O157:H7 in Fresh Produce and Mechanism of Action

Jiayi Wang,Yue Lei,Yougui Yu,Lebin Yin,Yangyang Zhang

DOI: https://doi.org/10.3390/foods10102406

IF: 5.2

2021-10-11

Foods

Abstract:Escherichia coli O157:H7 is frequently detected in ready-to-eat produce and causes serious food-borne diseases. The decontamination efficacy of lactic acid (LA) is clearly established. In this study, LA was mixed with acetic acid (AA) to reduce costs while achieving consistent or better inhibitory effects. Time-kill curves and inoculation experiments using fresh-cut spinach and arugula indicated that 0.8%LA+0.2%AA shows similar antibacterial effects to those of 1%LA. To determine whether 1%LA and 0.8%LA+0.2%AA exert antibacterial effects by similar mechanisms, proteomics analysis was used. The proteins related to macromolecule localization, cellular localization, and protein unfolding were uniquely altered after the treatment with 1%LA, and the proteins related to taxis, response to stress, catabolic process, and the regulation of molecular function were uniquely altered after the treatment with 0.8%LA+0.2%AA. Based on these findings, combined with the results of a network clustering analysis, we speculate that cell membrane damage is greater in response to LA than to 0.8%LA+0.2%AA. This prediction was supported by cell membrane permeability experiments (analyses of protein, nucleotide, ATP, and alkaline phosphatase leakage), which showed that LA causes greater membrane damage than 0.8%LA+0.2%AA. These results provide a theoretical basis for the application of an acid mixture to replace LA for produce decontamination.

food science & technology
Using ultrasonic washing combined with UV-LEDs as a novel chemical-free method to disinfect fresh ready-to-eat produce

Jiayi Wang,Sen Ma,Ning Zhou,Xiaofei Yang,Jun Xing,Jingyang Hong

DOI: https://doi.org/10.1016/j.ultsonch.2024.106926

IF: 9.336

2024-05-26

Ultrasonics Sonochemistry

Abstract:The consumption of ready-to-eat fresh produce raises the issue of food-borne pathogen infections; thus, disinfecting ready-to-eat produce for commercial use, such as in homes and restaurants, is important to ensure food safety. Chemical sanitizers are typically used for disinfection. Ultraviolet-light emitting diodes (UV-LEDs) are a novel non-thermal disinfection technology that consumes less energy and generates less heat than traditional UV lamps, making them more appealing to consumers. In this study, we combined ultrasonic (US) washing method with UV-LEDs (US-UV-LEDs) to develop a technique for disinfecting fresh produce without using chemical sanitizers and compared its efficacy with three common household sanitizers ("84" (sodium hypochlorite) disinfectant, kettle descaler (citric acid), and vinegar (acetic acid)). In addition, we investigated the efficacy of this method in controlling pathogen numbers in the water used to wash (washing water) the produce to prevent cross-contamination between water and produce. Cherry tomatoes and lettuce were selected as produce models and Salmonella Typhimurium and Escherichia coli O157:H7 were used as the bacterial models. The results showed that US-UV-LEDs reduced the numbers of S. Typhimurium and E. coli O157:H7 on produce by 2.1–2.2 log CFU/g, consistent with the results achieved by the three household sanitizers; however, kettle descaler and vinegar had a limited effect (2.6–3.5 log CFU/mL) on residual pathogens in the washing water. Furthermore, we created washing water with low (754 mg/L) and high (1425 mg/L) chemical oxygen demand (COD) levels and determined the disinfection efficacy of "84" disinfectant and US-UV-LEDs. The results showed that US-UV-LEDs reduced the number of S. Typhimurium and E. coli O157:H7 by 2.0–2.1 and 1.8–2.1 log CFU/g under low and high COD levels, respectively, which was similar a result to that of "84" disinfectant. However, the residual pathogen numbers in the washing water were reduced to 1.4–1.9 log CFU/mL after treatment with US-UV-LED under high COD, whereas the pathogens were undetected in the washing water disinfected with "84" disinfectant. These results suggest that US-UV-LEDs have better application potential than acidic household sanitizers, but chlorine sanitizer remains the most effective disinfecting method.

chemistry, multidisciplinary,acoustics
Methodology for modeling the disinfection efficiency of fresh-cut leafy vegetables wash water applied on peracetic acid combined with lactic acid

S Van Haute,F López-Gálvez,V M Gómez-López,Markus Eriksson,F Devlieghere,Ana Allende,I Sampers

DOI: https://doi.org/10.1016/j.ijfoodmicro.2015.05.020

2015-09-02

Abstract:A methodology to i) assess the feasibility of water disinfection in fresh-cut leafy greens wash water and ii) to compare the disinfectant efficiency of water disinfectants was defined and applied for a combination of peracetic acid (PAA) and lactic acid (LA) and comparison with free chlorine was made. Standardized process water, a watery suspension of iceberg lettuce, was used for the experiments. First, the combination of PAA+LA was evaluated for water recycling. In this case disinfectant was added to standardized process water inoculated with Escherichia coli (E. coli) O157 (6logCFU/mL). Regression models were constructed based on the batch inactivation data and validated in industrial process water obtained from fresh-cut leafy green processing plants. The UV254(F) was the best indicator for PAA decay and as such for the E. coli O157 inactivation with PAA+LA. The disinfection efficiency of PAA+LA increased with decreasing pH. Furthermore, PAA+LA efficacy was assessed as a process water disinfectant to be used within the washing tank, using a dynamic washing process with continuous influx of E. coli O157 and organic matter in the washing tank. The process water contamination in the dynamic process was adequately estimated by the developed model that assumed that knowledge of the disinfectant residual was sufficient to estimate the microbial contamination, regardless the physicochemical load. Based on the obtained results, PAA+LA seems to be better suited than chlorine for disinfecting process wash water with a high organic load but a higher disinfectant residual is necessary due to the slower E. coli O157 inactivation kinetics when compared to chlorine.
Innovative Hurdle Strategies for Listeria Control on Food-Contact Surfaces: A Peroxyacetic Acid-Steam Approach

Zi Hua,Mei-Jun Zhu

DOI: https://doi.org/10.3390/foods13162481

IF: 5.2

2024-08-07

Foods

Abstract:The persistence of Listeria monocytogenes biofilms on equipment surfaces poses a significant risk of cross-contamination, necessitating effective surface decontamination strategies. This study assessed the effectiveness of hurdle treatments combining peroxyacetic acid (PAA) and saturated steam against 7-day-old L. innocua (a non-pathogenic surrogate for L. monocytogenes) biofilms on stainless steel (SS), polyester (PET), and rubber surfaces. Results demonstrated >6 log10 CFU/coupon L. innocua reductions on SS and PET surfaces after PAA (40 ppm, 1 min) followed by steam treatment (100 °C, 6 s). On rubber surfaces, PAA (80 ppm, 1 min) followed by steam treatment (100 °C, 6 s) resulted in ~5 log10 CFU/coupon L. innocua reduction. The presence of apple juice soil reduced the efficacy of hurdle treatments, with PAA (40 ppm, 1 min) and steam exposure (6 s) resulting in 5.6, 5.8, and 4.2 log10 CFU/coupon reductions of L. innocua on SS, PET, and rubber, respectively. The efficacy of this antimicrobial combination was further reduced by surface defects, especially in the presence of organic matter. Nevertheless, the treatment still achieved >5 log10 CFU/coupon reductions of L. innocua on worn SS and PET soiled with apple juice and ~4.5 log10 CFU/coupon reduction on worn, soiled rubber surfaces. These findings highlight that PAA treatments followed by a brief steam exposure are effective strategies for controlling Listeria on food-contact surfaces.
Efficacy of Ozone to Reduce Bacterial Populations in the Presence of Substance of Citrus Fruits

Dan Wu,Jianchu Chen,Xingqian Ye,Junyan Zhang

DOI: https://doi.org/10.1109/icecc.2011.6068071

2011-01-01

Abstract:Ozone is a strong oxidizer and antiseptic. The efficacy of ozone to reduce bacterial populations in the presence of substance of citrus fruits has been studied here, included a Gram-positive bacterium, a Gram-negative bacterium and a spore former. The suspension quantitative bactericidal test was carried out. Five substrates, that were respectively sterile Class C buffer, 1% sucrose solutions,l% citric acid solution, 1% pectin solution(from citrus fruits) and 1% orange juice , were inoculated with vegetative cells of Escherichia coli or Staphylococcus aureus or spores of Bacillus subtilis, and ozonated at 0.4mg/L for 2min and lOmin. It is showed that the citric acid provided no protective effects and the bacterial populations reductions is far fewer compared to the sterile Class C buffer as blank control. Sucrose, pectin and orange juice provided protective effects to the bacterial populations, the protection varied with the different bacterial.
Investigation on the inactivation effect and mechanism of Listeria monocytogenes in fresh-cut cucumber during storage by ultrasound combined with sodium hypochlorite

Wanfu Hou,Yue Ma,Chunhong Zhang,Wenting Zhao,Shuang Zhao,Pan Wang,Xiaoyan Zhao,Dan Wang

DOI: https://doi.org/10.1016/j.ultsonch.2023.106706

Abstract:Fresh agricultural products are frequently contaminated with Listeria monocytogenes (L. monocytogenes), which threatens consumer health. The mechanism of the inhibitory effect of ultrasound and sodium hypochlorite (US-NaClO) on L. monocytogenes on fresh-cut cucumber remains poorly understood. Therefore, the bactericidal ability and mechanism of US-NaClO treatment on L. monocytogenes were studied on fresh-cut cucumber during storage using various approaches such as determination of intracellular material leakage, scanning electron microscopy, flow cytometry, and expression analysis of virulence genes. The results showed that the number of L. monocytogenes on fresh-cut cucumber was significantly reduced after ultrasound treatment for 5 min in combined with 75 ppm sodium hypochlorite treatment(P < 0.05). The US-NaClO treatment affected cell morphology, impaired cell membrane integrity, increased cell membrane permeability, and reduced the concentration of K+, inorganic phosphate, ATP, proteins, and DNA in bacterial cells, leading to the inactivation of microorganisms. In addition, the US-NaClO treatment downregulated expression of the virulence genes actA, hly, inlA, mpl, pclA, and plcB, thus decreasing the pathogenicity of bacteria. It can avoid contamination by pathogenic bacteria during the production of fresh-cut cucumber, while providing safety assurance for production.
Combined Effect of Thermosonication and Slightly Acidic Electrolyzed Water to Reduce Foodborne Pathogens and Spoilage Microorganisms on Fresh-cut Kale

Ahmad Rois Mansur,Deog-Hwan Oh

DOI: https://doi.org/10.1111/1750-3841.12888

Abstract:This study evaluated the efficacy of individual treatments (thermosonication [TS+DW] and slightly acidic electrolyzed water [SAcEW]) and their combination on reducing Escherichia coli O157:H7, Listeria monocytogenes, and spoilage microorganisms (total bacterial counts [TBC], Enterobacteriaceae, Pseudomonas spp., and yeast and mold counts [YMC]) on fresh-cut kale. For comparison, the antimicrobial efficacies of sodium chlorite (SC; 100 mg/L) and sodium hypochlorite (SH; 100 mg/L) were also evaluated. Each 10 g sample of kale leaves was inoculated to contain approximately 6 log CFU/g of E. coli O157:H7 or L. monocytogenes. Each inoculated or uninoculated samples was then dip treated with deionized water (DW; control), TS+DW, and SAcEW at various treatment conditions (temperature, physicochemical properties, and time) to assess the efficacy of each individual treatment. The efficacy of TS+DW or SAcEW was enhanced at 40 °C for 3 min, with an acoustic energy density of 400 W/L for TS+DW and available chlorine concentration of 5 mg/L for SAcEW. At 40 °C for 3 min, combined treatment of thermosonication 400 W/L and SAcEW 5 mg/L (TS+SAcEW) was more effective in reducing microorganisms compared to the individual treatments (SAcEW, SC, SH, and TS+DW) and combined treatments (TS+SC and TS+SH), which significantly (P < 0.05) reduced E. coli O157:H7, L. monocytogenes, TBC, Enterobacteriaceae, Pseudomonas spp., and YMC by 3.32, 3.11, 3.97, 3.66, 3.62, and >3.24 log CFU/g, respectively. The results suggest that the combined treatment of TS+SAcEW has the potential as a decontamination process in fresh-cut industry.
Investigation on the Microbial Diversity of Fresh-Cut Lettuce during Processing and Storage Using High Throughput Sequencing and Their Relationship with Quality

Yeting Sun,Xiaoyan Zhao,Yue Ma,Zhihong Ma,Zhaoying He,Wenting Zhao,Pan Wang,Shuang Zhao,Dan Wang

DOI: https://doi.org/10.3390/foods11121683

IF: 5.2

2022-06-08

Foods

Abstract:Microbial community distribution in vegetables can affect their quality. This study analyzed the distribution of the microbial community at various stages during processing and storage with the microbial diversity analysis, and evaluated the correlation between the dominant bacteria and sensory quality of lettuce using correspondence analysis with multiple regression analysis. Results showed that the process of washing, cutting, then disinfection and dewatering could change the community distribution and dominant bacteria in lettuce, and maintain better texture, morphology, aroma, color qualities of lettuce. The total number of colonies and relative abundance of Xanthomonas in fresh-cut lettuce decreased, while Afipia and Ralstonia increased during processing and pre-storage (storage for 6 h, 12 h and 1 d). After storage for 3 d, the total number of colonies in lettuce increased (more than 5 log CFU/g), especially the relative abundance of Pseudomonas, which led to the obvious deterioration of the sensory quality of lettuce. Throughout the process, the number of Bacillus cereus, Staphylococcus aureus, and E. coli was less than 100 CFU/g and 3 MPN/g. The number of typical pathogenic bacteria, Salmonella, Listeria monocytogenes and E. coli O157:H7, was below the detection limit. Overall, the prevention and control of psychrotrophic Pseudomonas in lettuce was still necessary. These results will provide useful information for the fresh-cut lettuce industry.

food science & technology
Antibacterial and antibiofilm performance of low-frequency ultrasound against Escherichia coli O157:H7 and its application in fresh produce

Mei Bai,Jinming Dai,Changzhu Li,Haiying Cui,Lin Lin

DOI: https://doi.org/10.1016/j.ijfoodmicro.2023.110266

2023-09-02

Abstract:Ultrasound technology has been focused on due to its unique advantages in biofilm removal compared with traditional antibacterial methods. Herein, the anti-biofilm properties of low-frequency ultrasound (LFUS) were studied against Enterohemorrhagic Escherichia coli O157: H7 (E. coli O157:H7). After ultrasonication (20 kHz, 300 W) for 5 min, the removal rate of biofilm from polystyrene sheets reached up to 99.999 %. However, the bacterial cells could not be inactivated completely even extending the duration of ultrasonic irradiation to 30 min. Fortunately, this study indicated that LFUS could efficiently weaken the metabolic capacity and biofilm-forming ability of bacterial cells separated from biofilm. It could be associated with the removal of cell surface appendages and damage to cell membrane induced by mechanical vibration and acoustic cavitation. Besides, the genetic analysis proved that the transcription level of genes involved in curli formation was significantly down-regulated during ultrasonic irradiation, thus impeding the process of irreversible adhesion and cells aggregation. Finally, the actual application effect of LFUS was also evaluated in different fresh produces model. The results of this study would provide a theoretical basis for the further application of ultrasound in the food preservation.
Effect of organic acids on biofilm formation and quorum signaling of pathogens from fresh fruits and vegetables

Balagopal Amrutha,Kothandapani Sundar,Prathapkumar Halady Shetty

DOI: https://doi.org/10.1016/j.micpath.2017.08.042

Abstract:Organic acids are known to be used as food preservatives due to their antimicrobial potential. This study evaluated the ability of three organic acids, namely, acetic acid, citric acid and lactic acid to manage E. coli and Salmonella sp. from fresh fruits and vegetables. Effect of these organic acids on biofilm forming ability and anti-quorum potential was also investigated. The effect of organic acids on inactivation of E. coli and Salmonella sp. on the surface of a selected vegetable (cucumber) was determined. The minimum inhibitory concentration of the organic acids were found to be 1.5, 2 and 0.2% in E. coli while it was observed to be 1, 1.5 and 1% in Salmonella sp. for acetic, citric and lactic acids respectively. Maximum inhibition of biofilm formation was recorded at 39.13% with lactic acid in E. coli and a minimum of 22.53% with citric acid in Salmonella sp. EPS production was affected in E. coli with lactic acid showing reduction by 13.42% while citric acid and acetic acid exhibited only 6.25% and 10.89% respectively. Swimming and swarming patterns in E. coli was notably affected by both acetic and lactic acids. Lactic and acetic acids showed higher anti-quorum sensing (QS) potential when compared to citric acid. 2% lactic acid showed a maximum inhibition of violacein production by 37.7%. Organic acids can therefore be used as potential quorum quenching agents in food industry. 2% lactic acid treatment on cucumber demonstrated that it was effective in inactivating E. coli and Salmonella sp. There was 1 log reduction in microbial count over a period of 6 days after the lactic acid treatment. Thus, organic acids can act as effective potential sanitizers in reducing the microbial load associated with fresh fruits and vegetables.
Extending More than One Week the Shelf Life of Fresh-Cut Lettuce Using Vinegar Enriched in Bioactive Compounds Encapsulated in α-Cyclodextrins

María de Los Ángeles Martínez-Sánchez,Ginés Benito Martínez-Hernández,Antonio López-Gómez

DOI: https://doi.org/10.3390/foods13193142

IF: 5.2

2024-10-01

Foods

Abstract:Fresh-cut salads are highly appreciated by consumers due to their healthy and convenient nature. Fresh-cut (FC) lettuce is one of the best-selling FC products due to its freshness and low preparation time for salads. However, FC lettuce is very perishable and, in addition, has been recently associated with severe foodborne illness alerts. Alternative natural sanitizing treatments to conventional sodium hypochlorite are needed. The antimicrobial activity of vinegar has been well-known since ancient times. In addition, bioactive compounds from plant byproducts are widely recognized for their antioxidant properties. This work aimed to evaluate the use of a novel and encapsulated vinegar powder enriched with bioactive compounds from fruit byproducts with high antimicrobial and antioxidant properties to preserve the physicochemical (titratable acidity, total soluble solids, weight loss, and color), microbial (psychrophiles, enterobacteria, lactic-acid bacteria, molds, and yeasts), and sensory quality of FC lettuce at 4 °C for up to 10 days. Small to no differences were observed in terms of physicochemical quality (≈0.1% titratable acidity; 2.3-3.3% total soluble solids; <1% weight loss) in comparison to control samples through storage. Vinegar treatments reduced by 2-4 log CFU g-1 the microbial loads after 10 days. In addition, a synergistic sensory antibrowning effect (greener and less yellowish appearance, showing -a* and -b*) between organic acids and the released polyphenols from the encapsulated plant byproduct extracts was observed. Hence, the enriched encapsulated vinegar represents an effective green alternative to conventional sanitizers to maintain the quality of FC lettuce through storage time.
Enhanced photodynamic inactivation against Escherichia coli O157:H7 provided by chitosan/curcumin coating and its application in food contact surfaces

Pengmin Zhang,Shuang Li,Wenxiu Wang,Jianfeng Sun,Zhizhou Chen,Jie Wang,Qianyun Ma

DOI: https://doi.org/10.1016/j.carbpol.2024.122160

IF: 10.723

2024-04-14

Carbohydrate Polymers

Abstract:Sterilisation technologies are essential to eliminate foodborne pathogens from food contact surfaces. However, most of the current sterilisation methods involve high energy and chemical consumption. In this study, a photodynamic inactivation coating featuring excellent antibacterial activity was prepared by dispersing curcumin as a plant-based photosensitiser in a chitosan solution. The coating generated abundant reactive oxygen species (ROS) after light irradiation at 420 nm, which eradicated ≥99.999 % of Escherichia coli O157:H7. It was also found that ROS damaged the cell membrane, leading to the leakage of cell contents and cell shrinkage on the basis of chitosan. In addition, the production of ROS first excited the bacterial antioxidant defence system resulting in the increase of peroxidase (POD) and superoxide dismutase (SOD). ROS levels exceed its capacity, causing damage to the defence system and further oxidative decomposition of large molecules, such as DNA and proteins, eventually leading to the death of E. coli O157:H7. We also found the curcumin/chitosan coating could effectively remove E. coli O157:H7 biofilms by oxidative of extracellular polysaccharides and proteins. All the contributors made the chitosan/curcumin coating an efficient detergent comparable with HClO.

polymer science,chemistry, organic, applied
Compositional shifts in fresh-cut apples microbiome in response to application of Lactiplantibacillus plantarum assessed by next-generation sequencing

Qian Zhao,Mingxuan Shi,Yu Jiang,Binshuo Hu,Xusheng Guo,Di Gong,Ying Zhang

DOI: https://doi.org/10.1016/j.lwt.2023.115627

IF: 6.056

2024-01-01

LWT

Abstract:Spoilage caused by microorganisms is the main problem of fresh-cut fruits during storage, leading to quality deterioration and short shelf life. Lactic acid bacteria (LAB) contribute to fruit preservation by producing secondary metabolites with antibacterial activity, like bactericins, organic acids, and extracellular polysaccharides, etc. In the study, the effects of Lactiplantibacillus plantarum BX62 and LP1-4 on the composition and dynamics of the microbiome on the surface of fresh-cut apples were investigated. L. plantarum survived and remained stable (>7 log CFU/mL). The cell suspensions (9 log cells/mL) of BX62, LP1-4, and BX62+LP1-4 showed varying degrees of antagonistic activity against microorganisms on the surface of fresh-cut apples during cold storage. Moreover, L. plantarum treatment inhibited the increase of bacterial diversity, and their cell suspensions also reduced the relative abundance of Actinobacteria, Acidobacteria, Basidiomycota, Rhodococcus, Pantoea, Ralstonia, Vishniacozyma, and Cystofilobasidium on the surface of fresh-cut apples. The results provide new insight into the characterization of microbial communities on the surface of fresh-cut apples after LAB treatment, which might assist in developing new biocontrol agents to control the microbial contamination of fruits.

food science & technology

Reduction of Escherichia coli O157:H7 and naturally present microbes on fresh-cut lettuce using lactic acid and aqueous ozone

Inactivation Mechanism of Escherichia Coli Induced by Slightly Acidic Electrolyzed Water.

Inactivation of Escherichia Coli O157:H7 and Salmonella and Native Microbiota on Fresh Strawberries by Antimicrobial Washing and Coating.

Antimicrobial Films and Coatings for Inactivation of Listeria Innocua on Ready-To-Eat Deli Turkey Meat

Decontamination of Escherichia coli O157:H7 on fresh Romaine lettuce using a novel bacteriophage lysin

Sequential Treatment with Slightly Acidic Electrolyzed Water (SAEW) and UVC Light-Emitting Diodes (Uvc-Leds) for Decontamination of Salmonella Typhimurium on Lettuce

Use of aqueous ozone rinsing to improve the disinfection efficacy and shorten the processing time of ultrasound-assisted washing of fresh produce

Use of Essential Oil Emulsions to Control Escherichia coli O157:H7 in the Postharvest Washing of Lettuce

Use of Acetic Acid to Partially Replace Lactic Acid for Decontamination against Escherichia coli O157:H7 in Fresh Produce and Mechanism of Action

Using ultrasonic washing combined with UV-LEDs as a novel chemical-free method to disinfect fresh ready-to-eat produce

Methodology for modeling the disinfection efficiency of fresh-cut leafy vegetables wash water applied on peracetic acid combined with lactic acid

Innovative Hurdle Strategies for Listeria Control on Food-Contact Surfaces: A Peroxyacetic Acid-Steam Approach

Efficacy of Ozone to Reduce Bacterial Populations in the Presence of Substance of Citrus Fruits

Investigation on the inactivation effect and mechanism of Listeria monocytogenes in fresh-cut cucumber during storage by ultrasound combined with sodium hypochlorite

Combined Effect of Thermosonication and Slightly Acidic Electrolyzed Water to Reduce Foodborne Pathogens and Spoilage Microorganisms on Fresh-cut Kale

Investigation on the Microbial Diversity of Fresh-Cut Lettuce during Processing and Storage Using High Throughput Sequencing and Their Relationship with Quality

Antibacterial and antibiofilm performance of low-frequency ultrasound against Escherichia coli O157:H7 and its application in fresh produce

Effect of organic acids on biofilm formation and quorum signaling of pathogens from fresh fruits and vegetables

Extending More than One Week the Shelf Life of Fresh-Cut Lettuce Using Vinegar Enriched in Bioactive Compounds Encapsulated in α-Cyclodextrins

Enhanced photodynamic inactivation against Escherichia coli O157:H7 provided by chitosan/curcumin coating and its application in food contact surfaces

Compositional shifts in fresh-cut apples microbiome in response to application of Lactiplantibacillus plantarum assessed by next-generation sequencing