Abstract:The accurate numerical simulation of projectile penetration process is a complex challenge. Experimental investigation of these time-dependent non-linear events is expensive and time-consuming. In this paper, 3-D numerical simulations are carried out to estimate the penetration performance of designed penetrators against the double and triple brick-wall, plain concrete wall and light armor targets at impact velocities of 120 to 300 m/s, undergoing normal and oblique impacts. In all simulations, both the projectile and targets are modeled using Lagrange solver facility, available in ANSYS/Autodyn. During penetration process, targets experience severe grid deformation in the region local to the penetrator. Highly distorted elements are removed from the calculation using erosion strain algorithm. The simulation results suggest that at maximum velocity flat-nose (FN) projectile successfully perforate all the targets with significant residual velocity, for both normal and maximum oblique impact scenarios. For impact velocity of 120 m/s, the FN projectile perforated the armor and concrete targets but was not able to penetrate and cross through these targets. However, both brick-wall targets were perforated at normal and maximum oblique angle with sufficient residual velocity. The validation of the calculated results and numerical setup were made with experiments against double and triple brick-wall targets for impacting velocity of 170 m/s. Good agreement between the experimental and estimated projectile residual velocity has been achieved. In contrast to FN projectile, the ogive-nose penetrator calculated results has shown ricocheting behavior on impacting the light armor target at minimum velocity and maximum obliquity. The FN projectile has shown better perforation and penetration performance against light armor and domestic targets. The projectile minimum velocity is also estimated numerically to fully penetrate three different types of targets. These results would be beneficial for the designers and operators to get the desired performance against domestic and light armor targets with sureness. Keywords: Numerical simulation, Oblique impact, Perforation, Penetration, Brick-wall

Evaluation of semi‐analytical model for rigid projectile penetration into concrete/metal targets

Investigation on the anti-penetration performance of the steel/nylon sandwich plate

High Velocity Penetration of Concrete Targets with Eroding Long- Rod Projectiles; An Experiment and Analysis

Experimental Studies on Kinetic Projectile's Direct Penetrations with Low-speed Against Reinforced Concrete Targets

A Dynamic Cavity Expansion Model for Rigid Projectile Penetration into Concrete considering the Compressibility and Nonlinear Constitutive Relations

Numerical Studies of Penetration in Light Armor, Concrete and Brick-Wall Targets

Computer Simulation Study of Kinetic Energy Projectiles Penetrating Concrete Targets

Numerical Analysis of Deformation and Failure of Penetration into Concrete Target by Projectile

Numerical Simulation Of High-Speed Projectile Oblique Penetration Into The Concrete Target

Experimental and 3D Mesoscopic Numerical Simulation Study of Kinetic Projectile Penetrating into Concrete

Research on mass loss and nose shape evolution of kinetic energy projectiles penetrating concrete at high velocity

Experimental and theoretical study on steel long-rod projectile penetration into concrete targets with elevated impact velocities

Numerical studies on resistance of concrete target under rigid projectile impact using Perzyna-type visco-damage model

Numerical Simulation of Multifunctional Projectile Penetrating Reinforced Concrete Target Plate Based on Sensor Data Acquisition

Investigation on anti-penetration performance of reinforced concrete targets based on ANSYS/LS-DYNA

SIMULATION ANALYSIS OF HIGH VELOCITY PENETRATION INTO CONCRETE TARGET

Thick Plain Concrete Targets Subjected to High Speed Penetration of 30crmnsini2a Steel Projectiles: Tests and Analyses

Terminal ballistic and static impactive loading on thick concrete target

Numerical analysis of projectile penetration and perforation of plain and fiber reinforced concrete slabs

Cylindrical Cavity Expansion Model for Projectile Normally Penetrating into Concrete Target

Analytical and experimental study on elliptical cross-section double-ogive-nose projectile penetration into plain concrete target