Abstract:Concrete structures are seriously deteriorated under marine environment because marine water is aggressive in nature; it contains salts of sulphate and chloride and others. These salts deteriorate the plain and reinforced concrete structures. However, most of previous research was investigated on concrete performances exposed to single solution, such as sulphate or chloride attack, even though the actual conditions are the combination of both. Therefore, the object of this study is to evaluate the performances of concrete containing coal bottom ash (CBA) with different fineness as a supplementary cementitious material (SCM) exposed to seawater. This study considered 10% ground CBA as a SCM in concrete. The original CBA was ground in a ball mill for 20 and 30 h, to get different particle fineness. Initially all specimens were cured in normal water for 28 days as to achieve targeted strength and then half of the specimens were shifted into seawater for further 28, 56, 90 and 180 days and other specimens were kept in normal water. The particle fineness of CBA influence on the concrete performances was assessed in terms weight variations, compressive strength and chloride permeability. Experimental results demonstrated that concrete strength with CBA of fineness 3836 cm2/g (type-A) delivers around 11.9% and 8.5% higher than control mix in water and seawater respectively at 180 days. Subsequently, concrete strength with CBA fineness of 3895 cm2/g (type-B) brings about 12.7% and 5.8% greater than control mix in water and seawater respectively at 180 days. However, it was also detected that concrete with CBA-type-A and CBA-type-B exhibits around 45.4% and 42.4% reduction in chloride penetration as compared to control mix at 180 days. Hence, it was concluded the strength performances of CBA-type-B is superior than the control mix at 28 days. However, CBA-type-A gives the better performances at later ages of 90 and 180 days. Hence, CBA-type-A is suggested for the future studies, based on strength performances and resistance to chloride penetration. This study encourages the use of ground CBA in concrete as SCM in normal as well as in marine environment.

Effect of Bagasse Ash Admixture on Corrosion Behavior of Low Carbon Steel Reinforced Concrete in Marine Environment

Effect of Sugarcane Bagasse Ash and Ceramic Waste Dust as Partial Replacements of Portland Cement on Corrosion Behavior of HRB400 Low Carbon Steel Reinforcement in 3.5 % NaCl

Steel Corrosion and Corrosion-Induced Cracking in Reinforced Concrete with Carbonated Recycled Aggregate

Effect of modified supplementary cementitious material on performance of mortar and concrete in marine environment

Calcined Clay and Limestone as Partial Replacements of Portland Cement: Electrochemical Corrosion Behavior of Low Carbon Steel Rebar as Concrete Reinforcement in Corrosive Environment

Effects of Environmental Water-Level Changes and Bidirectional Electromigration Rehabilitation on Durability of Concrete

Technology for Enhancing Durability of Structures of Sea-sand Concrete and Its Application

Coal bottom ash as a sustainable supplementary cementitious material for the concrete exposed to seawater

Chloride transport resistance of alkali-activated concrete exposed to combined chloride, sulfate and carbonation environment

Mechanical Performance and Chloride Penetration of Calcium Sulfoaluminate Concrete in Marine Tidal Zone

Performances of concrete containing coal bottom ash with different fineness as a supplementary cementitious material exposed to seawater

Corrosion Behavior of AISI 1018 Reinforcing Steel in Sustainable Concrete made with Sugar Cane Bagasse Ash and Recycled Aggregates Exposed in Seawater

Effects of Cyclic Seawater Exposure on the Mechanical Performance and Chloride Penetration of Calcium Sulfoaluminate Concrete

Influence of Reinforcement Mesh Configuration for Improvement of Concrete Durability

Enhancing Concrete Durability and Strength with Fly Ash, Steel Slag, and Rice Husk Ash for Marine Environments

Concrete Admixed with Modified Auxiliary Cementing Materials for Real Sea Service

Bidirectional Electromigration of A Corrosion Inhibitor in Chloride Contaminated Concrete

Study on the Behavior and Durability of Reinforced Concrete in Boric Acid Environment

Different Effects of Fly Ash and Slag on Anti-Rebar Corrosion Ability of Concrete with Chloride Ion

EXPERIMENTAL STUDY ON REBAR CORROSION EMBEDDED IN CONCRETE AFFECTED BY MINERAL ADMIXTURE

A numerical study on chloride transport in alkali-activated fly ash/slag concretes