Abstract:To clear the effects of the hydrodynamic interactions among neighboring vapor bubbles on the saturated pool boiling heat transfer, artificial nucleation sites with several cavity arrangements were manufactured on the substrate surface and measured liquid temperatures near heated substrate by a miniature thermocouple probe with 10 kHz. The surface temperature of heated substrate was measured by an infrared camera with 1 kHz and bubble dynamics were simultaneously visualized by a high-speed video camera with 5 kHz and 10 kHz, respectively. The liquid temperature fluctuations, measured with micro thermocouple 100 mu m and 10 mu m above the substrate surface, were compared among each other and with the transient temperature fields obtained through IR measurements. Results showed that the hydrodynamic interaction among neighboring bubbles causes the liquid convection, that was only detected 100 mu m above the boiling surface. Generally, the degree of liquid temperature fluctuations at 10 mu m height and different arrangements of nucleation sites was under 1 K. Here the superheated sublayer in the vicinity of the boiling surface was generally not affected by the convection. Only when the coalescence from two neighboring nucleation sites occurred and the liquid-vapor interface nearly reached the substrate, a steep temperature drop over 2 K was detected. It was concluded that the viscous sublayer stably exists during boiling of water in lower heat flux conditions. To enhance the convective heat transfer in nucleate boiling, coalesced bubble needs to peel off the viscous sublayer during its deformation. Based on the measurements in this study, this peel-off effect only happens when the coalescence point is less than 1 mm above the heated surface.

High-speed visualization and image processing of sub-atmospheric water boiling on a transparent heater

Observation and Analysis of the Detachment Frequency of Coalesced Bubbles in Pool Boiling Liquid Nitrogen

Visualization of the Evolution of a Single Vapor Bubble During Boiling of a Subcooled Liquid: Experience in Automating the Processing of High-Speed Video Recording Results

A Review of Pool-Boiling Processes Based on Bubble-Dynamics Parameters

Direct Numerical Simulation and Visualization of Subcooled Pool Boiling

ICONE23-1761 AN EXPERIMENTAL STUDY ON BUBBLE BEHAVIORS IN FORCED CONVECTIVE SUBCOOLED BOILING OF HIGH SUBCOOLINGS

Influence of Hydrodynamic Interactions among Multiple Bubbles on Convective Heat Transfer in Nucleate Boiling

Numerical Study on Bubble Departing Behavior from Heated Surface in Subcooled Pool Boiling

Bubble departure and sliding in high-pressure flow boiling of water

Experimental study of the influence of bubble interaction on their characteristics during transient boiling in a flow of subcooled liquid

Investigation of Bubble Behavior in Subcooled Flow Boiling of Water in a Horizontal Annulus Using High-Speed Flow Visualization

High-speed Visualization of Bubble Behaviors for Pool Boiling of R-141b

Visualization Study on Bubble Dynamical Behavior in Subcooled Flow Boiling under Various Subcooling Degree and Flowrates

The Visual Experiment of Boiling Crisis Triggering Process During Subcooled Flow Boiling

Heat exchange units boiling process numerical modeling at subatmospheric pressure

HIGH-SPEED VISUALIZATION OF TRAJECTORY AND SHAPE CHANGE OF VAPOR BUBBLE IN SUBCOOLED FLOW BOILING

Visualization of Flow Boiling Experiments on Micro/Nanoscale Structured Surfaces in Microchannel

EXPERIMENTAL AND VISUALIZATION STUDY OF BOILING PHENOMENA IN SUPERFLUID HELIUM II

Thin Liquid Film Dynamics and Bubble Behavior in Flow Boiling

Visualized Investigation of Gas–liquid Stratified Flow Boiling of Water in a Natural Circulation Thermosyphon Loop with Horizontal Arranged Evaporator