Abstract:Lotus seedpods (LSPs) are an abundant and underutilized agricultural residue discarded from lotus seed production. In this study, ZnCl2 and FeCl3 coactivation of LSP for one-pot preparation of magnetic activated carbon (MAC) was explored for the first time. X-ray diffraction (XRD) results showed that Fe3O4, Fe0, and ZnO crystals were formed in the LSP-derived carbon matrix. Notably, transmission electron microscopy (TEM) images showed that the shapes of these components consisted of not only nanoparticles but also nanowires. Fe and Zn contents in MAC determined by atomic absorption spectroscopy (AAS) were 6.89 and 3.94 wt%, respectively. Moreover, SBET and Vtotal of MAC prepared by coactivation with ZnCl2 and FeCl3 were 1080 m2/g and 0.51 cm3/g, which were much higher than those prepared by single activation with FeCl3 (274 m2/g and 0.14 cm3/g) or ZnCl2 (369 m2/g and 0.21 cm3/g). MAC was subsequently applied as an oxidation catalyst for Fenton-like degradation of acid orange 10 (AO10). As a result, 0.20 g/L MAC could partially remove AO10 (100 ppm) with an adsorption capacity of 78.4 mg/g at pH 3.0. When 350 ppm H2O2 was further added, AO10 was decolorized rapidly, nearly complete within 30 min, and 66% of the COD was removed in 120 min. The potent catalytic performance of MAC might come from the synergistic effect of Fe0 and Fe3O4 nanocrystals in the porous carbon support. MAC also demonstrated effective stability and reusability after five consecutive cycles, when total AO10 removal at 20 min of H2O2 addition slightly decreased from 93.9 ± 0.9% to 86.3 ± 0.8% and minimal iron leaching of 1.14 to 1.19 mg/L was detected. Interestingly, the MAC catalyst with a saturation magnetization of 3.6 emu/g was easily separated from the treated mixture for the next cycle. Overall, these findings demonstrate that magnetic activated carbon prepared from ZnCl2 and FeCl3 coactivation of lotus seedpod waste can be a low-cost catalyst for rapid degradation of acid orange 10.

Fabrication of magnetic activated carbon from waste macroporous resin via Fenton’s reagent impregnation

Synthesis of magnetic activated carbons from black liquor lignin and Fenton sludge in a one-step pyrolysis for methylene blue adsorption

Preparation and characterization of activated carbon from wool waste and the comparison of muffle furnace and microwave heating methods

Preparation of an activated carbon involving magnetic properties

Magnetic Fe-doping G-C3n4/graphite: the Effect of Supporters and the Performance in Fenton-like Reactions

Magnetic Activated Carbon from ZnCl2 and FeCl3 Coactivation of Lotus Seedpod: One-Pot Preparation, Characterization, and Catalytic Activity towards Robust Degradation of Acid Orange 10

Preparation and Evaluation of a Magnetite-Doped Activated Carbon Fiber for Enhanced Arsenic Removal

Facile Fabrication of Magnetic Carbon Composites from Hydrochar Via Simultaneous Activation and Magnetization for Triclosan Adsorption.

Green synthesis of magnetic mesoporous carbon from waste-lignin and its application as an efficient heterogeneous Fenton catalyst

Fabrication of N-doped graphitic carbon encapsulated Fe3C/Fe nanoparticles with dual-reaction centers for highly effective Fenton-like degradation of organic pollutants

Controllable synthesis of magnetic carbon composites with high porosity and strong acid resistance from hydrochar for efficient removal of organic pollutants: An overlooked influence

Magnetic biochar based on furfural residue as an excellent candidate for efficient adsorption of Tetracycline, Bisphenol A, Congo red, and Cr6+

One-step Preparation of Coal-based Magnetic Activated Carbon with Hierarchically Porous Structure and Easy Magnetic Separation Capability for Adsorption Applications

Polymer-based porous carbon doped with iron nanoparticles for enhanced organic compounds removal

Preparation of magnetic activated carbon fibers@Fe3O4 by electrostatic self-assembly method and adsorption properties for methylene blue

Investigation of the Adsorption Process of Chromium (VI) Ions from Petrochemical Wastewater Using Nanomagnetic Carbon Materials

Novel and High-Performance Magnetic Carbon Composite Prepared from Waste Hydrochar for Dye Removal

Oxidative Hydrothermal Carbonization to Fabricate Versatile Magnetic Biochar for Fenton-Like Degradation of Phenolic Compounds

Recycling of Fe 3 O 4 nanomaterial from coal fly ash as catalyst to develop green and sustainable bio-electro Fenton: Characterization, optimization, and performance

Utilization of Macadamia Nutshell Residue for the Synthesis of Magnetic Activated Carbon toward Zinc (II) Ion Removal

Efficient removal of perfluorinated compounds from water using a regenerable magnetic activated carbon.