Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

Sulfate of potash and yellow phosphorus to simultaneously remove SO2–NO and obtain a complete fertilizer

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

Simultaneous Removal of Sulfur Dioxide and Nitrogen Oxide from Flue Gas by Phosphorus Sludge: the Performance and Absorption Mechanism

Simultaneous removal of SO2 and NOx from flue gas by phosphorus sludge: the performance and absorption mechanism

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Recent Advances in Elimination of SO<sub>2</sub> and NO<sub> <i>x</i> </sub> from Flue Gas Employing Phosphorus Sludge and Phosphate Rock

Recent Advances in Elimination of SO2 and NOx from Flue Gas Employing Phosphorus Sludge and Phosphate Rock

A Novel Dry Process for Simultaneous Removal of So2 and No from Flue Gas in A Powder-Particle Fluidized Bed

Simultaneous removal of SO2 and NOx by combination of ozone oxidation and Na2S2O3solution spray

An Adaptive Sorbent for the Combined Desulfurization/Denitration Process Using a Powder-Particle Fluidized Bed

Simultaneous wet absorption of SO2 and NOX with mixed Na2SO3 and (NH4)2SO3: Effects of mass concentration ratio and pH

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Investigation on removal of noX and SO2 from flue gas by combined ozone with absorption and by-product treatment

Preparation and application of MgO-loaded tobermorite to simultaneously remove nitrogen and phosphorus from wastewater

High Efficient Removal Of So2 And No Of Flue Gas In A Single Fluidized Bed Reactor

Removal of SO2 and NOx from flue gas using mud-phosphorus slurry

Simultaneous Absorption of SO2 and NO from Flue Gas Using Ultrasound/fe2+/heat Coactivated Persulfate System

Wet Oxidation and Absorption Procedure for NOx Removal

Simultaneous Removal of SO2 and NO by FeII(EDTA) Solution: Promotion of Mn Powder and Mechanism of Reduction

Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO

Removal of NO and SO_2 from Flue Gas by Wet Scrubbing Using Aqueous NaClO Solution