Calcium-Magnesium-Aluminum-Silicate (CMAS) Corrosion Resistance of Y-Yb-Gd-Stabilized Zirconia Thermal Barrier Coatings

Tongxin Wang,Fang Shao,Jinxing Ni,Huayu Zhao,Yin Zhuang,Jing Sheng,Xinghua Zhong,Jiasheng Yang,Shunyan Tao,Kai Yang
DOI: https://doi.org/10.1007/s11666-020-01142-2
IF: 2.839
2021-01-01
Journal of Thermal Spray Technology
Abstract:It was published that zirconate coatings containing Gd/Yb and yttria-stabilized zirconia (YSZ) coatings with high Y content had good calcium-magnesium-aluminum-silicate (CMAS) corrosion resistance. However, there are few reports on CMAS resistance of zirconia-based thermal barrier coatings (TBCs) doped with Y, Gd and Yb. This article intends to explore the role of Y, Gd and Yb in resisting CMAS corrosion of zirconia-based TBCs. The purpose is to optimize the rare earth modification of zirconia-based TBCs. 8YSZ and ZrO<sub>2</sub>-9.5Y<sub>2</sub>O<sub>3</sub>-5.6Yb<sub>2</sub>O<sub>3</sub>-5.2Gd<sub>2</sub>O<sub>3</sub> free-standing TBCs were produced by air plasma spraying (APS) with commercial powders. The CMAS corrosion behavior and failure mechanism of these coatings were studied by heat treatment at 1350 °C. The microstructure and composition were characterized. The results showed the CMAS deposited on the surface of 8YSZ/YSZ-Yb-Gd coatings gradually penetrated into coatings. ZrSiO<sub>4</sub> and m-ZrO<sub>2</sub> were observed in the shallow layer of coatings. The diffusion rate of Y<sup>3+</sup> in coatings into CMAS was greater than that of Gd<sup>3+</sup> and Yb<sup>3+</sup>. Compared with YSZ coatings, CMAS penetrated deeper in YSZ-Yb-Gd coatings after the same corrosion time. The spallation of YSZ-Yb-Gd coatings occurred earlier than 8YSZ. In general, adding a small amount of Yb and Gd did not improve the CMAS resistance of YSZ TBCs.
materials science, coatings & films
What problem does this paper attempt to address?