Abstract:Adding hydrogen to natural gas is a promising way to improve the ignition stability and reduce the greenhouse gas emissions of pilot-ignition direct-injection natural gas engines. Most of the previous studies concerning hydrogen-enriched natural gas engines are focused on spark-ignition engines. The limited investigations on the addition of hydrogen in direct-injection natural gas engines are conducted by experimental method. Therefore, some detailed information on the in-cylinder combustion and emission formation process are left unknown. In this work, numerical simulations have been performed for the combustion process of a pilot-ignition direct-injection natural gas engine based on an integrated mechanism which is capable of describing the chemical kinetics involving diesel, natural gas, and hydrogen. Three-dimensional (3D) computational fluid dynamics simulations were conducted at different hydrogen blend ratios to explore the effects of hydrogen addition on the whole combustion process and the mole fraction traces of small radicals as well as CO, NOx, and soot emissions. Hydrogen addition was achieved by both volume-equivalent principle and energy-equivalent principle to guide the choice of hydrogen-addition method. Zero-dimensional simulations were conducted to elaborate the explanations of the phenomena in 3D simulations and disclose the interactions among the sensitivity of the key reactions, the formation of the active radicals, and the heat release process. The results show that the ignition delay is shortened and the ignition of natural gas is enhanced with the increase of hydrogen addition, which is primarily caused by the enhanced reactions related to active small radicals induced by increased hydrogen concentration. When hydrogen is added based on the volume-equivalent principle, all emission values will reduce with little sacrifice on thermal efficiency at hydrogen blend ratios smaller than 20%. However, CO emissions experience an increasing trend when hydrogen blend ratio is further increased to higher than 20% while NOx and soot emissions retain the decreasing trend. When hydrogen is added based on the energy-equivalent principle, CO emissions and soot emissions will decrease with the increase of hydrogen blend ratio while NOx emissions will witness an opposite trend with considerable improvements in thermal efficiency.

Advantages of hydrogen addition in a passive pre‐chamber ignited SI engine for passenger car applications

Enhancing the Performance of a Spark-Ignition Methanol Engine with Hydrogen Addition

Role of the Compression Ratio in Dual-Fuel Compression Ignition Combustion with Hydrogen and Methanol

The performance of a spark ignition gasoline engine with hydrogen addition under low-load conditions

Study on Combustion Behaviors and Cycle-by-cycle Variations in a Turbocharged Lean Burn Natural Gas S.I. Engine with Hydrogen Enrichment

Experimental investigation of hydrogen combustion in a single cylinder PFI engine

Quantitative assessment of small-bore gasoline direct injection engine for homogenous stoichiometric lean condition with hydrogen addition in dual fuel mode

Exploring the passive the pre-chamber ignition concept for spark-ignition engines fueled with natural gas under EGR-diluted conditions

Improving the Performance of a Gasoline Engine with the Addition of Hydrogen–oxygen Mixtures

Computational Study of Hydrogen Direct Injection for Internal Combustion Engines

Potential of hydrogen addition to natural gas or ammonia as a solution towards low- or zero-carbon fuel for the supply of a small turbocharged SI engine

Experimental Study on the Effects of Hydrogen Injection Strategy on the Combustion and Emissions of a Hydrogen/Gasoline Dual Fuel SI Engine under Lean Burn Condition

A Review of the Use of Hydrogen in Compression Ignition Engines with Dual-Fuel Technology and Techniques for Reducing NOx Emissions

Effects of Hydrogen Addition on the Performance of a Pilot-Ignition Direct-Injection Natural Gas Engine: A Numerical Study

Numerical Study on the Combustion Characteristics of an Ammonia/Hydrogen Engine with Active Prechamber Ignition

Combustion and emissions characteristics of a hybrid hydrogen–gasoline engine under various loads and lean conditions

Effects of Hydrogen Addition on Cycle-By-Cycle Variations in A Lean Burn Natural Gas Spark-Ignition Engine

Optimization of combustion and performance parameters by intake-charge conditions in a small-scale air-cooled hydrogen fuelled SI engine suitable for use in piston-prop aircraft

A Comprehensive Analysis of Hydrogen–Gasoline Blends in SI Engine Performance and Emissions

Effect of hydrogen direct injection on natural gas/hydrogen engine performance under high compression-ratio conditions

Effects of hydrogen injection strategy on the hydrogen mixture distribution and combustion of a gasoline/hydrogen SI engine under lean burn condition