Abstract:The base post-grouting technology is widely used in pile foundation engineering to improve its behavior. For super-long piles, due to the large compression of pile shaft, conventional static load tests cannot effectively test the effect of post-grouting at the pile base. This study introduced a novel method to test the effect of base post-grouting of three 88 m long piles. A total of three test piles were grouted at the bottom of the piles. The grouting amount of the No. 1 pile was 500 kg, the No. 2 pile was 250 kg, and the No. 3 pile was 0 kg. The transmitted wave method in the pile and dynamic penetration method were used in combination to quantitatively evaluate the effect of base post-grouting on the soil below the pile base. The influencing range of base post-grouting was firstly evaluated by the transmitted wave method in the pile, and the strength of the soil before and after grouting under the same pile base was measured by the dynamic penetration method. The test results showed that: the depth of the pile base reinforcement was 2 m for No. 1 pile, and 1 m for No. 2 pile, which was consistent with the grouting amount; the elastic modulus of the soil below the pile base after base post-grouting was about twice that of the soil before base post-grouting; the strength of the soil below pile base was largely improved after grouting; and the bearing capacity of the base soil layer increased from 35.5% to 41.7% when the grouting amount increased from 250 kg to 500 kg.

Field test research on post-grouting effect for super-long cast-in-place bored pile in thick soft foundation

A Novel Method for Testing the Effect of Base Post-Grouting of Super-Long Piles

Field Tests on Behavior of Pre bored Grouted Planted Pile in Soft Soil Area with Existing Pile Foundation

Experimental Analysis of Bearing Capacity of Cast-in-place Tubular Pile

Experimental study on vertical bearing performance of base post-grouted cast-in-place plies in soft soils

In-situ test of bearing capacity behavior of composite foundation with rigid-flexible piles

Analysis of cast-in-situ tubular piles in soft foundation improvement at bridge approaches

In-situ Experiment on Urban Road Subgrade Improved by Plain Concrete Pile and Mixed-in-place Pile

Field Test on the Influence of the Cemented Soil Around the Pile on the Lateral Bearing Capacity of Pile Foundation

Experimental Study on Bearing Capacity Behavior of Deep Large Diameter Cast-in-place Belled Pile

Field Tests on Behavior of Pre-Bored Grouted Planted Pile and Bored Pile Embedded in Deep Soft Clay

Field Tests of the Lateral Monotonic and Cyclic Performance of Jet-Grouting-Reinforced Cast-In-Place Piles

Testing and Modeling the Behavior of Pre-Bored Grouting Planted Piles under Compression and Tension

Experimental Study on Post-Grouting Pile Vertical Bearing Performance Considering Different Grouting Methods and Parameters in Cohesive Soil

A test on base bearing capacity of static drill rooted nodular pile

Field Tests and Simplified Calculation Method for Static Drill Rooted Nodular Pile

Field study on the behavior of pre-bored grouted planted pile with enlarged grout base

Laboratory tests on the frictional capacity of core pile - cemented soil interface

Field Test Study on the Improvement Mechanism of Pile-Net Composite Foundation

Laboratory Model Study on the Pile-Forming Mechanisms and Bearing Deformation Characteristics of CFA Piles

Field investigations on bearing characteristics of composite post-grouting piles in clastic rock layers