Abstract:The spatial liquid-phase concentrations were measured by means of an electrical conductivity probe in a 0.289-m ID bubble column operated at superficial gas velocities (ug) of 0.018, 0.031 and 0.038 m/s, respectively. The column was equipped with a perforated plate gas distributor (0.002 mø × 31 holes). Carbon dioxide was used as a tracer gas, whereas deionized water was used as a liquid phase. The local liquid-phase axial dispersion coefficient EL was derived from the local liquid-phase concentrations by means of the graphical method developed by Khang and Kothari (1980). It was found that the spatial distribution of the local EL coefficients becomes radially non-uniform as a function of ug. At the regime transition velocity (Utrans = 0.031 m/s) between bubbly and transition flow regimes the mean, EL coefficient for the upper zone (UZ) becomes identical to the one for the lower zone (LZ). At both lower and higher ug values EL(UZ) is systematically higher than EL(LZ). The same result also holds if the overall bubble bed (BB) is divided into core and annulus regions. It was proven that, in the bubbly flow regime (ug < Utrans), EL (core region) ≈ EL (annulus region), whereas in the transition flow regime (ug > Utrans), EL (annulus region) > EL (core region). The effect of the aerated liquid height L on the spatial distribution of the local EL coefficients was studied, as well. Three different BBs, viz. L = 0.64 m (shallow BB), 1.28 m (medium BB) and 2.1 m (deep BB) were examined at ug = 0.038 m/s. The spatial distribution of the local EL coefficients was most scattered in the shallow BB (L = 0.64 m). In a medium BB with an aerated liquid height L = 1.28 m the existence of a well-developed helical flow structure was detected. It was shown that the graphically determined mean EL coefficient (for the overall BB) increases as a function of both the superficial gas velocity ug and aerated liquid height L, and a useful empirical correlation was derived. It covers the following range of bed aspect ratios: 2.1 ≤ L/Dc ≤ 7.3.

Flow pattern study, gas hold-up and gas liquid mass transfer correlations in a bubble column: Effect of non — coalescing water — organic mixtures

Study on bubble size distribution and local gas holdup in bubble column

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Studies on hydrodynamics of slurry turbulent bubble column(Ⅰ) Gas holdup and its radial distribution

Experiment and Numerical Simulation of the Motion of Bubble Swarm in a Bubble Column

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Numerical Simulations Of Fluid Dynamics And Mixing In A Large Shallow Bubble Column: Effects Of The Sparging Pipe Allocations For Multiple-Pipe Gas Distributors

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

CFD Simulation of Gas-Liquid Flow in Bubble Column

Modeling of Mass Transfer Characteristics of Bubble Column Reactor with Surfactant Present

Effect of Particles on Hydrodynamics and Mass Transfer in a Slurry Bubble Column: Correlation of Experimental Data

Experimental study and CFD simulation of mass transfercharacteristics of a gas-induced pulsating flow bubblecolumn

THE EFFECT OF SOLUTES ON BUBBLE SIZE IN AIR-WATER DISPERSIONS

Experimental study of interfacial mass transfer from single CO2 bubbles ascending in stagnant water

Bubbling Behaviors Induced by Gas-Liquid Mixture Permeating Through A Porous Medium

Distinctly Different Bubble Behaviors in A Bubble Column with Pure Liquids and Alcohol Solutions

The Effect of Superficial Gas Velocity and Aerated Liquid Height on the Spatial Distribution of Local Liquid-Phase Axial Dispersion Coefficients in a Bubble Column

Experimental Analysis of Flow Characteristics in a Gas-Liquid-Solid Three-Phase Bubble Column

2D and 3d Simulations of Fluid Dynamics in the Bubble Reactor for Liquid Fuel Synthesis: Comparisons Against Experiments

Gas-Liquid Mass Transfer in A Slurry Bubble Column Reactor under High Temperature and High Pressure

Gas-Liquid Mass Transfer in Microbubble Column Reactors