Influencing Factors on Sand Removal Efficiency in Aerated Grit Chamber
Liwei Xin,Bo Li,Guangxue Wu,Ganlin Wu,Qun Liao,Kexin Guo
DOI: https://doi.org/10.15890/j.cnki.jsjs.2017.08.003
2017-01-01
Abstract:One reclaimed treatment plant was selected to investigate the factors affecting operating performance of the aerated grit chamber.Components and size distribution of influent particles were studied.A pilot scale aerated grit chamber was designed and operated to clarify the effect of hydraulic retention time (HRT),aeration density,aeration distribution and pre-aeration on the particles removal performance.There were more particles with a small particle size than that with a large particle size in inflow and the particles with a size smaller than 0.076 mm was the dominant component in influent particles.A high proportion of organic matters was observed in influent particles,with a VSS/SS ratio of 67.5％.Particles removal could be improved by extending the HRT.Under HRT of 5,10 min and 20 min,the grits removal efficiency in system was 11.5％,31.6％ and 48.8％,respectively.An appropriate aeration density had positive effects on particles removal while an excessive aeration had a negative effect.Under air to water ratio of 0.05,0.1 and 0.2,the particles removal efficiency was 33.52％,23.02％ and 19.19％,respectively.Aeration distribution had large impact on particles removal,under three aeration strategies,namely equality aeration rate,low aeration intensity/high intensity and high aeration intensity/low aeration intensity,a high removal efficiency of 41.23％ was achieved under the high aeration intensity/low aeration intensity strategy.By pre-aeration and setting a dam board after pre-aeration area,particles removal efficiency increased because of an extension of effective settling time.The removal efficiency was 46.79％ with only pre-aeration in the system,which was much higher than that with pre-aeration/normal aeration and only normal aeration.