Abstract:During the tunneling process of earth pressure balance (EPB) shield machines, the undrained compressibility of foam-conditioned soils in the excavation chamber is essential for reducing the fluctuation of chamber pressure and guaranteeing effective tunnel face support. As conditioned soil is simplified to be radially constrained by the shield shell and in a quasi-one-dimensional compression state under the face pressure along the tunneling direction, a mechanism-inspired analytical model was developed to estimate the void ratio and pore pressure of foam-conditioned coarse-grained soils (FCS) in one-dimensional compression based on effective stress analysis. In the model, an expansion coefficient was proposed to characterize the filling state of foam bubbles in pores and a void ratio threshold (eth) was defined as the transition point of the FCS with and without effective stress. The variation of void ratio and pore pressure with total stress of FCS in two distinct stages of the void ratio (e), either greater or smaller than its threshold, were calculated based on Boyle’s law and the hyperbolic assumption of the effective stress–strain relation of soil. A good agreement between the analytical and experimental results verified the reliability of the proposed analytical method. Furthermore, a parametric study indicated that the compressibility increases with an increase in the expansion coefficient and foam injection ratio (FIR). Increasing additional water content leads to a decrease in compressibility under low pressure (σv ≤ 20 kPa), but an increase in compressibility under high pressure (σv > 20 kPa). Meanwhile, the pore pressure in FCS in the stage of e < eth also positively correlates with the expansion coefficient, FIR, and additional water content. The research findings would provide a convenient method to estimate the undrained compressibility behavior of FCS and theoretically guide the soil conditioning optimization in EPB tunneling.

Characterization and Computational Fluid Simulation of Conditioned Muck During EPB Shield Tunneling in Gravelly Sand Stratum

STUDY OF GROUND HEAVE AND SUBSIDENCE INDUCED BY SHIELD TUNNELLING IN SOFT GROUND

Identification of Abnormal Operating Conditions and Intelligent Decision System

Numerical simulation of cutterhead and soil interaction in slurry shield tunneling

Investigation of the Dynamic Characteristics of Muck during EPB Shield Tunnelling in a Full Chamber Model Using a CFD Method

Supporting Pressure for Earth Pressure Balance Tunnel Face Stability when Tunneling is Implemented in Saturated Sandy Soil

Earth Pressure Balance Control for EPB Shield

Earth pressure balance shield tunneling in sandy gravel deposits: a case study of application of soil conditioning

A Unified Analytical Model for Undrained Compressibility Behavior of Foam-Conditioned Coarse-Grained Soils Based on Effective Stress Analysis

Numerical study on the muck flow behavior in the screw conveyor during EPB shield tunneling

Effect of Grain Gradation on the Permeability Characteristics of Coarse-grained Soil Conditioned with Foam for EPB Shield Tunneling

A Novel Calculation Model for the Permeability Coefficient of Soils Conditioned with Foam and Bentonite Slurry

Experimental study on workability and permeability of sandy soils conditioned with thickened foam

A new method to quantify rheology of conditioned soil for application in EPB TBM tunneling

Effects of Soil Conditioning on Characteristics of a Clay-Sand-Gravel Mixed Soil Based on Laboratory Test

Micromechanical Investigation of Suffusion and Its Consequence in Gap-Graded Granular Soil at the Opening of Underground Structures Using the Coupled CFD-DEM Method

Coupled Filtration-Consolidation Model for Vacuum-Preloaded Soft Ground

Undrained compressibility characteristics and pore pressure calculation model of foam-conditioned sand

A Modified Wedge-Prism Model for Calculating the Limit Support Pressure of a Shallow Shield Tunnel Face in Unsaturated Sandy Soil

Effect of conditioning schemes on mechanical properties of EPB shield soil

STUDY ON SOIL-COMPACTING EFFECTS INDUCED BY EARTH PRESSURE BALANCE SHIELD CONSTRUCTION