Gas turbine-based system taking advantage of LNG regasification process for multigeneration purposes; Techno-economic-environmental analysis and machine learning optimization
Yinquan Hu,Samir I. Badrawi,JITENDRA KUMAR,Hala Najwan Sabeh,Theyab R Alsenani,Fahid Riaz,Tamim Alkhalifah,Salem Alkhalaf,Fahad Alturise,Jitendra Kumar,Theyab R. Alsenani
DOI: https://doi.org/10.1016/j.psep.2023.08.068
2023-09-13
Process Safety and Environmental Protection: Transactions of the Institution of Chemical Engineers, Part B
Abstract:It is viable for engineers to determine how thermodynamic systems can benefit from heat recovery in order to improve efficiency, reduce costs, and lower carbon dioxide emissions . The authors of the study propose a new energy system that incorporates various cycles and units, including gas turbines, Rankine and two organic Rankine cycles , an absorption refrigeration unit, a proton exchange membrane (PEM) electrolyzer , and a liquefied natural gas (LNG) unit. The hydrogen produced is stored and transferred for use as fuel. The system was modeled and optimized using MATLAB programming software, with a parametric study and sensitivity analysis conducted before employing a genetic algorithm optimization to find the most suitable performance conditions. Modifying the compressor's pressure ratio within the range of 6–18 caused a shift in the cooling load, ranging from 45 to 36 MW. Nonetheless, these adjustments in pressure ratio yielded a reduction of 0.4 Cent/kWh in levelized cost of electricity (LCOE) and 0.15 /h, the exergy efficiency is 39.03%, and the normalized CO 2 emissions are 335.89 kg/GJ. However, the optimization results showed a reduced total cost rate of 1884.50 $/h, along with an improved exergy efficiency from 39.03% to 40.32% and a decrease in annual CO 2 emissions from 211,000 metric tons to 175,000 metric tons. The implementation of artificial neural networks (ANN) has significantly decreased the time required for optimization from 47 h to just 16 min. This research attempts to present a polygeneration system with five various products to recover waste heat of an externally-fired gas turbine cycle driven by biomass fuel. First, the waste heat of the gas turbine cycle is utilized in a supercritical Brayton cycle for more power generation. Then, it is employed as a heat source in an organic Rankine cycle and a hot water unit. The power generated in the organic Rankine cycle is used to produce freshwater in a reverse osmosis desalination system. Finally, liquefied natural gas acts as a heat sink for the supercritical Brayton cycle and organic Rankine cycle. The subsystem based on the liquefied natural gas is responsible for the production of cooling and required electricity of an electrolysis unit for hydrogen production. The tri-objective optimization of the designed system, using four supercritical gases in the supercritical Brayton cycle, reveals that the system has the best performance by using nitrogen. The system exergy efficiency is improved by 7.8 % points due to the integration of the subsystems with the gas turbine cycle. The proposed system can generate electricity, heating, and cooling relatively equivalent to 8126 kW, 2023 kW, and 1305 kW, respectively. The rates of hydrogen and freshwater production are equal to 14.28 kgh-1 and 45.81 kgs-1 , correspondingly. In the context of environmental analysis, sustainability index and exergoenvironmental index were calculated as 2.365 and 0.6354. Coking dry gas is a kind of refinery dry gas, which is rich in H 2 and light hydrocarbon resources, but it's often used as fuel, resulting in inefficient utilization of dry gas resources and a large amount of air pollutants emissions. Solid oxide fuel cell can efficiently convert the chemical energy of hydrogen into electricity. Therefore, this work establishes a model of a power generation process of coking dry gas reforming coupled with the solid oxide fuel cell and organic Rankine cycle. Process simulation is used to analyze the influence of key operating parameters on the system output performance. The obtained results indicate that the net electrical efficiency of the proposed system is increased from 45.45 % of the coking dry gas direct combustion for power generation system to 56.89 %. In terms of environmental impact, the CO 2 emissions of the new system is 373.31 kg/MWh, 20.12 % lower than that of the direct combustion process. Besides, the effect of air excess ratio on system performance is evaluated and the net electrical efficiency of the proposed system increases to 63.73 % as the air excess ratio decreases from 2.0 to 1.1. The above results show that the proposed hybrid power system can provide an effective way for efficient and clean utilization of coking dry gas. The demand for natural gas (NG) is increasing rapidly due to the world energy crisis. Liquefied Natural Gas (LNG) technology is one of the most flexible and reliable supply solutions, which has already been a major research hotpot in energy -Abstract Truncated-
English Else