Abstract:Compared to traditional biomass and coal-fired power plants, a process that includes integrated pyrolysis and subsequent gasification is a promising technology to deliver a larger electrical output through the production of high-purity hydrogen with a low carbon footprint. Chemical looping can further enhance the biomass contribution to the global renewable energy demand while fulfilling the stringent CO2 emission cuts needed in the energy sector. This study aims at investigating the feasibility of developing a solar catalytic chemical looping biomass refinery (SCCLBR) power plant for sustainable production of energy using a comprehensive plant modeling and techno-economic assessment. The plant is composed of 7 sequential units: i) biomass preparation (drying, transferring, and grinding), ii) reacting unit (SCCLBR), iii) water gas shift unit and heat recovery, iv) CO2 and H2S separation (Rectisol Process), v) sulfur removal (Claus Process), vi) air separation and vii) catalyst regeneration. The simulation was performed for 1–6 tonne/hour of biomass as input. The effect of key variables (feedstock load, water injection, and temperature) on the economic performance of the plant were analyzed. The simulated results of the chemical looping reactor were validated against the experimental results, while the results of Rectisol and air separation units were validated against the thermodynamic simulation. The results demonstrated that the CCLBR (without solar integration) and integrated SCCLBR can reach the efficiency of 34% and 41% respectively, yet the results have not been optimized. The sensitivity analysis indicated that water injection rate is the most influential parameter, which can even suppress the impact of biomass loading rate. A separate thermodynamic simulation was also performed to investigate the reaction equilibrium of oxygen carrier regeneration (Ca2Fe2O5) using CO2. The results demonstrated that a temperature above 730 °C is required to avoid carbonation (Fe2O3 and CaCO3 production). The maximum greenhouse gas emission in SCCLBR is 10.70, which is significantly lower than traditional coal-to-hydrogen and biomass-to-hydrogen power plants. It has also been found that across varying feedstock input rates, greenhouse gas emissions average 12.8% lower when solar PV supplements refinery power needs; optimization of the steam/biomass ratio may reduce emissions even further.

Exergy and techno-economic evaluation of solar-driven coal gasification coupled CLHG cogeneration system

Energy Characteristic of Concentrated Solar Coal Gasification System Based on Experiment and Model Analysis

Proposal and energetic and exergetic evaluation of a hydrogen production system with synergistic conversion of coal and solar energy

Energy and Exergy Analysis of Poly-Generation System of Hydrogen and Electricity Via Coal Partial Gasification

Performance of hydrogen and power co-generation system based on chemical looping hydrogen generation of coal

A novel hydrogen production system based on the three-step coal gasification technology thermally coupled with the chemical looping combustion process

Thermodynamic Analysis of a Solar Thermochemical Cycle-Based Direct Coal Liquefaction System for Oil Production

Techno-Economic Analysis of Hydrogen and Electricity Production by Biomass Calcium Looping Gasification

A techno-economic analysis of solar catalytic chemical looping biomass refinery for sustainable production of high purity hydrogen

Exergy estimate of a novel hybrid solar-gas power and organic Rankine cycle-based hydrogen-production system

Economic and Environmental Analyses of an Integrated Power and Hydrogen Production Systems Based on Solar Thermal Energy

Optimal Design and Thermodynamic Analysis on the Hydrogen Oxidation Reactor in a Combined Hydrogen Production and Power Generation System Based on Coal Gasification in Supercritical Water

Design and performance estimate of a novel linear Fresnel reflector solar-gas combined system for producing electricity and hydrogen

Synergistic solar energy integration for enhanced biomass chemical looping hydrogen production: Thermodynamics and techno-economic analyses

Co-production system of hydrogen and electricity based on coal partial gasification with CO 2 capture

Thermodynamic analysis of a novel hybrid fuel cell-combined cooling, heating-and power (CCHP) system-integrated solar-driven biomass gasification for achieving sustainable and efficient poly-generation

Exergy analysis of a coal/biomass co-hydrogasification based chemical looping power generation system

Thermodynamic analysis of a CCHP system with hydrogen production process by methane reforming enhanced by solar-assisted chemical looping adsorption

Exergoeconomic evaluation of a new carbon-free hydrogen and freshwater production system based on biomass gasification process

A novel integrated system for sustainable generation of hydrogen and liquid hydrocarbon fuels using the five-step ZnSI thermochemical cycle, biogas upgrading process, and solar collectors

Theoretical Energy Analysis and Environmental Evaluation of a New Coal Gasification System Based on Zn/ZnO Redox Pair