Abstract:Anaerobic digestion (AD) is an important step in waste recovery. In Colombia, the production of citrus food significantly contributes to environmental impact via waste generation. In 2021, the waste produced, specifically citrus rind, amounted to 725,035 tons/year. During degradation, wastes generate leachate and greenhouse gases (GHGs), which negatively impact water sources (leachate), soil, and human and animal health. This article describes the design of a two-phase biodigestion system for the degradation of organic matter and biogas production. The system uses citrus waste to produce biogas with neutral emissions. The biodigestion process begins with the stabilization of the methanogenesis reactor (UASB), which takes approximately 19 days. During this period, the biogas produced contains approximately 60% methane by volume. Subsequently, the packed bed reactor operates for 7 days, where hydrolytic and acetogenic bacteria decompose the citrus waste, leading to the production and accumulation of volatile fatty acids. The final step involves combining the two phases for 5 days, resulting in a daily biogas production ranging from 700 to 1100 mL. Of this biogas, 54.90% is methane (CH4) with a yield of 0.51 LCH4gSV−1. This study assesses the methane production capacity of citrus waste, with the process benefiting from the pH value of the leachate, enhancing its degradability. Consequently, this approach leads to a notable 27.30% reduction in solids within the digestion system. The two-phase anaerobic biodigestion system described in this article demonstrates a promising method to mitigate the environmental impact of citrus waste while concurrently producing a renewable source of energy.

Biogas production from the mechanically pretreated, liquid fraction of sorted organic municipal solid wastes

Comparison of High-Solids to Liquid Anaerobic Co-Digestion of Food Waste and Green Waste

Anaerobic–Aerobic Treatment of Fruit and Vegetable Wastes and Municipal Wastewater

Assessment of the Feasibility of Converting the Liquid Fraction Separated from Fruit and Vegetable Waste in a UASB Digester

Effectiveness of Aerobic Pretreatment of Municipal Solid Waste for Accelerating Biogas Generation During Simulated Landfilling

Digestibility Improvement of Sorted Waste with Alkaline Hydrothermal Pretreatment

The Advantage of Citrus Residues as Feedstock for Biogas Production: A Two-Stage Anaerobic Digestion System

Improvement in Methane Concentration in the Biogas Produced through the Co-digestion of Food Waste and Mezcal Vinasses

Energy recovery from municipal solid waste in an anaerobic reactor

Acidogenic fermentation of biowaste coupled with nitrogen recovery using selective membranes to produce a VFA-rich liquid with a high C/N ratio

Bio-physical pre-treatments in anaerobic digestion of organic fraction of municipal solid waste to optimize biogas production and digestate quality for agricultural use

Characterization of municipal solid waste with the perspective of biofuels and bioproducts recovery in Northeast Mexico

Wet anaerobic digestion of organic fraction of municipal solid waste: experience with long-term pilot plant operation and industrial scale-up

Biowaste management by hydrothermal carbonization and anaerobic co-digestion: Synergistic effects and comparative metagenomic analysis

Thermally enhanced solid–liquid separation process in food waste biorefinery: modelling the anaerobic digestion of solid residues

Thermochemical Pretreatment for Anaerobic Digestion of Sorted Waste

Anaerobic Codigestion of Food Waste and Polylactic Acid: Effect of Pretreatment on Methane Yield and Solid Reduction

The effect of alkaline pretreatment on the anaerobic digestion of fruit and vegetable wastes from a central food distribution market

Anaerobic Digestibility Enhancement of Sorted Organic Waste by Alkaline Hydrothermal Pretreatment

Evaluation of Biogas Production from Different Biomass Wastes With/without Hydrothermal Pretreatment

High-Solids Anaerobic Digestion of Mixed Municipal and Industrial Waste