Abstract:The viability of hydrothermal pretreatment (HTP) to improve the efficiency of biogas production from municipal solid wastes (MSWs) is uncertain because there is always a trade-off between organic matters hydrolysis and recalcitrant melanoidins formation when applying HTP on different solid wastes. In this study, MSWs including waste activated sludge, fruit and vegetable residues, and kitchen wastes, with and without HTP were digested in the one phase and two-phase anaerobic digesters, respectively. Although the specific biogas production of MSWs in two-phase anaerobic digestion was significantly enhanced by HTP, no benefit could be found in one-phase anaerobic digestion because of the melanoidins formation. The specific biogas production of hydrothermally pretreated MSWs was much higher in two-phase anaerobic digestion (0.71 L biogas/g VSadded) than that of MSWs in one-phase anaerobic digestion with or without HTP (0.53 L and 0.55 L biogasig VSadded) when the butyric acid type fermentation dominated in the acidogenic phase. These findings indicated that the recalcitrant melanoidins formed in the HTP process were probably removed in the acidogenic digester. Differing from previous study, mixed-acid type fermentation, rather than ethanol type fermentation, was observed in the acidogenic digester fed with hydrothermally pretreated feedstock when pH was adjusted in the range of 4.0-4.5 with high oxidation reduction potential values of 49-97 my. The succeeding specific biogas production of mixed-acid type feedstock was only 0.59 L biogas/g VSadded, which was lower than that of the butyric acid type feedstock. Microbial community structure was independent of the pH valties and was substrate-specific in the acidogenic digesters. In the acidogenic digester with the HTP substrate, the phylum Firmicutes and Bacteroidetes increased, thereby possibly resulting from the increased content of soluble sugar and proteins in the HTP feedstock. Energy balance estimation of the four defined scenarios indicated that the combined HTP and two-phase AD in the MSWs treatment can achieve higher net energy output by 50.5-97.4% compared to the other three scenarios. This enables the combined process of HTP and two-phase AD to be a promising alternative way in the treatment of feedstock rich in protein and sugar. (C) 2016 Elsevier Ltd. All rights reserved.

Thermal characterization of anaerobic sludges from wastewater treatments applied to biological generation of H2

Biochemical Properties of Sludge Derived Hydrothermal Liquid Products and Microbial Response of Wastewater Treatment

Bio-hydrogen production from anaerobic fermentation of sludge pretreated with α-amylase

Energy recovery from high ash-containing sewage sludge: Focusing on performance evaluation of bio-fuel production

Strategies for the Revalorization of Sewage Sludge in a Waste Water Treatment Plant Through the Integration of Hydrothermal Processing

Anaerobic digestion of wastewater from hydrothermal liquefaction of sewage sludge and combined wheat straw-manure

System Integration of Hydrothermal Liquefaction and Anaerobic Digestion for Wet Biomass Valorization: Biodegradability and Microbial Syntrophy.

Thermophilic Hydrogen Production from Sludge Pretreated by Thermophilic Bacteria: Analysis of the Advantages of Microbial Community and Metabolism.

Optimisation of anaerobic co-digestion in two-stage systems for hydrogen, methane and biofertiliser production

Maximizing Bio-Hydrogen and Energy Yields Obtained in a Self-Fermented Anaerobic Bioreactor by Screening of Different Sewage Sludge Pretreatment Methods

Application of In-Situ H2-assisted Biogas Upgrading in High-Rate Anaerobic Wastewater Treatment.

Mass and energy integration study of hydrothermal carbonization with anaerobic digestion of sewage sludge

Evaluation of on-site biological treatment options for hydrothermal liquefaction aqueous phase derived from sludge in municipal wastewater treatment plants

Fermentative Hydrogen Production From Sewage Sludge

Evaluation of three methods for enriching H2-producing cultures from anaerobic sludge

Biohydrogen Production From Food Waste By Anaerobic Fermentation

Technical and financial evaluation of an emerging thermochemical technology for sustainable management of municipal wastewater sludge

Biomethane and biohydrogen production from an anaerobic sludge used in the treatment of rice parboiling effluent: Specific methanogenic and hydrogenic activity

Two-Phase Anaerobic Digestion of Municipal Solid Wastes Enhanced by Hydrothermal Pretreatment: Viability, Performance and Microbial Community Evaluation

The Bio-Hydrogen Production by Proteus, Shigella and Enterobacter Aerogenes from Wastewater Which Contained Teal Oil, Camellia Oil or Flaxseed Oil

Optimising sewage sludge anaerobic digestion for resource recovery in wastewater treatment plants