Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Study on Helicopter Antitorque Device Based on Cross-Flow Fan Technology

Airfoil Parameterization Evaluation Based on a Modified PARASEC Method for a H-Darrious Rotor

CFD Study of an Annular-Ducted Fan Lift System for VTOL Aircraft

Numerical Simulation and Aerodynamic Investigation of the Intermeshing Rotor in Hover

Active Flow Control of Helicopter Rotor Based on Coflow Jet

Aerodynamic analysis and modeling of coaxial ducted fan aircraft with the ceiling effect

Rotor Performance Analysis and Modeling of Multirotor Using Wind-Tunnel Test

Experimental Investigation on Aerodynamic Interactions of Canard Rotor/Wing Aircraft in Hover and Low Speed Forward Flight

Study On The Mechanism Of The Variable-Speed Rotor Affecting Rotor Aerodynamic Performance

The Overall Design of Variable Diameter Ducted Fan in the Aircraft

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

Research on Flight Dynamic Modeling and Interference of Components for Rotor/Wing Compound Helicopter

Aerodynamic Performance of a Small-Scale Tilt Rotor: Numerical Simulation and Experiment in Steady State

Design and Application of an Electric Tail Rotor Drive Control (ETRDC) for Helicopters with Performance Tests

Research on Aerodynamic Test Validation and the Vector Force Control Method for an E-STOL Fan Wing Unmanned Aerial Vehicle

Computational fluid dynamics trimming of helicopter rotor in forward flight

Experimental and numerical simulation investigation of a counter-rotating fan stage

An experimental and theoretical evaluation of micro rotor MCF3225 in static conditions

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Numerical simulation of the effect of helicopter flight advance ratio and lift rate on rotor aerodynamic noise