Abstract:The biological wastewater treatment using aerobic granular sludge is a new and very promising method, which is predominantly used in SBR reactors which have higher volumetric conversion rates than methods with flocculent sludge. With suitable reactor operation, flocculent biomass will accumulate into globular aggregates, due to the creation of increased substrate gradients and high shearing power degrees. In the research project described in this paper dairy wastewater with a high particle load was treated with aerobic granular sludge in an SBR reactor. A dynamic mathematical model was developed describing COD and nitrogen removal as well as typical biofilm processes such as diffusion or substrate limitation in greater detail. The calibrated model was excellently able to reproduce the measuring data despite of strongly varying wastewater composition. In this paper scenario calculations with a calibrated biokinetic model were executed to evaluate the effect of different operation strategies for the granular SBR. Modeling results showed that the granules with an average diameter of 2.5 mm had an aerobic layer in between 65-95 microm. Density of the granules was 40 kgVSS/m3. Results revealed amongst others optimal operation conditions for nitrogen removal with oxygen concentrations below 5 gO2/m3. Lower oxygen concentrations led to thinner aerobic but thicker anoxic granular layers with higher nitrate removal efficiencies. Total SBR-cycle times should be in between 360-480 minutes. Reduction of the cycle time from 480 to 360 minutes with a 50% higher throughput resulted in an increase of peak nitrogen effluent concentrations by 40%. Considering biochemical processes the volumetric loading rate for dairy wastewater should be higher than 4.5 kgCOD/(m3*d). Higher COD input load with a COD-based volumetric loading rate of 9.0 kgCOD/(m3*d) nearly led to complete nitrogen removal. Under different operational conditions average nitrification rates up to 5 gNH/(m3*h) and denitrification rates up to 3.7 gNO/(m3*h) were achieved.

Sludge granulation in an UASB–moving bed biofilm hybrid reactor for efficient organic matter removal and nitrogen removal in biofilm reactor

Biomass granulation in an upflow anaerobic sludge blanket reactor treating 500 m3/day low-strength sewage and post treatment in high-rate algal pond

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Rapid aerobic sludge granulation in an integrated oxidation ditch with two-zone clarifiers.

Formation and Characteristics of Aerobic Granular Sludge for Simultaneous Phosphorus and Nitrogen Removal in a SBR

Development of aerobic granulation system for simultaneous removal of C, N, and P in sequencing batch airlift reactor

Application of aerobic granular sludge in polishing the UASB effluent.

Post-treatment of anaerobically pre-treated molasses wastewater in an aerobic granular sludge sequencing batch reactor

Biochemical conversions and biomass morphology in a long-term operated SBR with aerobic granular sludge

COD removal from expanded granular sludge bed effluent using a moving bed biofilm reactor and their microbial community analysis

Enhanced aerobic sludge granulation in a Sequencing Batch Reactor (SBR) by applying mycelial pellets

Gas-enhanced operation and stepwise organic stressing as a new alternative in realising successful sludge granulation in high-rate anaerobic bioreactor for wastewater treatment

Aerobic granular sludge process: a fast growing biological treatment for sustainable wastewater treatment

Optimizing sequencing batch reactor (SBR) reactor operation for treatment of dairy wastewater with aerobic granular sludge

Granules as Precursors in the Working of Upflow Anaerobic Sludge Blanket Reactor: A Review on the Impacts of Granulation

Effective removal of organic substances and nutrients using microgranular sludge in a sequential batch reactor

Feasibility Study of Applying Anaerobic Step-Feeding Mode for the Treatment of High-Strength Wastewater in Granular Sequencing Batch Reactors (GSBRs)

Aerobic Granulation Strategy for Bioaugmentation of a Sequencing Batch Reactor (SBR) Treating High Strength Pyridine Wastewater.

Aerobic granular sludge formation in a sequencing batch reactor treating agro-industrial digestate

Enhanced granulation of activated sludge in an airlift reactor for organic carbon removal and ammonia retention from industrial fermentation wastewater: a comparative study

Aerobic Sludge Granulation in a Full-Scale Sequencing Batch Reactor