Abstract:Electroacoustic transducers arrays operating in the 50–100 kHz frequency range are currently being investigated for underwater applications such as target detection transducers installed on underwater autonomous vehicles (UAV) and detection of underwater intruders to protect and secure economically and strategically critical coastal areas and facilities. However, the frequency range is such that it prevents the use of monolithic piezoceramics operating in the thickness mode due to the unacceptably high voltages that are required to drive them. Whereas the alternative such as Langevin-type transducer solutions have certain other assembly difficulties that arise due to the size limitations imposed on the transducer from the half-wavelength (λ/2) arrangement requirement of the units. In our study, an entirely new alternative was proposed to overcome these difficulties. A piezoceramic transducer constructed from a hollow cylindrical shell form poled in the radial direction was designed and developed to operate at the longitudinal length extension mode. Since the hollow cylindrical piezoceramics were designed and produced with one end closed, this closed end was used as a passive cap with the transducer operating in a piston mode. ATILA finite element analysis code was used to design, analyze and fine-tune the dimensional requirements of the transducer. The center frequency of the transducer was fixed to 70 kHz. Commercial lead zirconate titanate (PZT) composition with hard piezoelectric character (PZT-4) was used as the starting powder. The slip casting method was used to obtain the cylindrical shell form. Single element transducers, as well as a hexagonal close-packed array consisting of seven units and arranged with a distance of half-wavelength (λ/2) to obtain constructive interference at 70 kHz were constructed and tested for underwater electroacoustic performance.

Numerical evaluation of acoustic emission (AE) sensors by lead-zirconate-titanate (PZT) geometric design

Design and Analysis of a PZT-based Micromachined Acoustic Sensor with Increased Sensitivity

A novel acoustic emission sensor design and modeling method for monitoring the status of high-speed train bearings

Fabrication and testing of high performance acoustic emission sensor with Ta-Doped lead zirconate titanate

Angular Measurement of Acoustic Reflection Coefficients by the Inversion of V(z, T) Data with High Frequency Time-Resolved Acoustic Microscopy

Design of a Triaxial Piezoelectric Accelerometer

Parametric Analysis and Optimization of Radially Layered Cylindrical Piezoceramic/Epoxy Composite Transducers

Feasibility Study of A Partially Released Lead-Zirconate-Titanate (pzt) Diaphragm Micro-Actuator

Porous PZT Ceramics with High Hydrostatic Figure of Merit and Low Acoustic Impedance by TBA-Based Gel-Casting Process

Optimal position and dimensions of embedded normal piezoelectric transducers, higher order plate models and experimental approach

A Theoretical and Empirical Investigation of Design Characteristics in a Pb(Zr,Ti)O3-Based Piezoelectric Accelerometer

Design, fabrication, and evaluation of high frequency, single-element transducers incorporating different materials

On the PZT/Si Unimorph Cantilever Design for the Signal-to-noise Ratio Enhancement of Piezoelectric MEMS Microphone

Wave Propagation Characteristics in A MEMS Piezoelectric Annular Plate: A Semi-analytical Study

Design, finite element analysis, fabrication and electroacoustic characterization of transducer arrays from piezoceramics with hollow cylindrical shell form

Numerical Characterization of Piezoceramics Using Resonance Curves

The design and test of MEMS piezoresistive ultrasonic sensor arrays

Measurements of Piezoelectric Coefficient d33 of Lead Zirconate Titanate Thin Films Using a Mini Force Hammer

Design and Simulation of A Novel Operation Mode of Integrated Ferroelectric Micro-Sensors

Effects of Air on Enclosure Design of Lead-Zirconate-Titanate (pzt) Thin-Film Diaphragm Microactuators

Performance Improvement of Ring-Type PZT Ceramics for Ultrasonic Dispersion System