MOF-Templated Preparation of Highly Dispersed Co/Al 2 O 3 Composite as the Photothermal Catalyst with High Solar-to-Fuel Efficiency for CO 2 Methanation
Xi Chen,Qiang Li,Meng Zhang,Juanjuan Li,Songcai Cai,Jing Chen,Hongpeng Jia
DOI: https://doi.org/10.1021/acsami.0c11576
2020-08-07
Abstract:CH<sub>4</sub> production from CO<sub>2</sub> hydrogenation provides a clean approach to convert greenhouse gas CO<sub>2</sub> into chemical energy, but high energy consumption in this reaction still restrains its further application. Herein, we use a light-driven CO<sub>2</sub> methanation process instead of traditional thermocatalysis by an electrical heating mode, with the aim of greatly decreasing the energy consumption. Under UV–vis–IR light irradiation, the photothermal CO<sub>2</sub> methanation over highly dispersed Co nanoparticles supported on Al<sub>2</sub>O<sub>3</sub> (Co/Al<sub>2</sub>O<sub>3</sub>) achieves impressive CH<sub>4</sub> production rates (as high as 6036 μmol g<sup>–1</sup> h<sup>–1</sup>), good CH<sub>4</sub> selectivity (97.7%), and catalytic durability. The high light-harvesting property of the catalyst across the entire solar spectrum coupled with its strong adsorption capacity toward H<sub>2</sub>, CO<sub>2</sub>, CO, and abundant active sites are proposed to be responsible for the better photothermocatalytic performance of Co/Al<sub>2</sub>O<sub>3</sub>. Furthermore, a novel light-promotion effect is also revealed in CO<sub>2</sub> methanation, where UV–vis light irradiation induces oxygen vacancies and improves the proclivity toward adsorption of H<sub>2</sub>, CO<sub>2</sub>, and CO, finally resulting in a significant enhancement of the photothermocatalytic activity for CH<sub>4</sub> production. By concentrating the low-intensity light (120 mW/cm<sup>2</sup>) via a Fresnel lens, a photothermal CO<sub>2</sub> conversion efficiency of more than 50% with a good CH<sub>4</sub> selectivity (76%) is achieved on the optimal catalyst under a dynamic reaction system, which indicates the bright prospect of photothermal CO<sub>2</sub> methanation.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acsami.0c11576?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acsami.0c11576</a>.Schematic diagram of the flow reaction setup; catalytic activity for CH<sub>4</sub> production via the photothermal route in the reported literature; SEM and HRTEM images of catalysts; CH<sub>4</sub> production over Al<sub>2</sub>O<sub>3</sub> and 21%Co/Al<sub>2</sub>O<sub>3</sub> catalyst under irradiation; XRD and TEM analysis of the spent catalyst; Temporal temperature evolution over the catalysts under irradiation; The full XPS spectra of 21%Co<sub>3</sub>O<sub>4</sub>/Al<sub>2</sub>O<sub>3</sub> and 21%Co/Al<sub>2</sub>O<sub>3</sub>; EPR spectra of the 21%Co/Al<sub>2</sub>O<sub>3</sub> and M-21%Co/Al<sub>2</sub>O<sub>3</sub> in the dark or under irradiation; and exhaust composition under irradiation and evolution of the relative concentrations of H<sub>2</sub>, CO<sub>2</sub>, CO, and CH<sub>4</sub> during in situ DRIFTS (<a class="ext-link" href="/doi/suppl/10.1021/acsami.0c11576/suppl_file/am0c11576_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.
materials science, multidisciplinary,nanoscience & nanotechnology