Enhancing carbon dioxide uptake in biochar derived from husk biomasses: Optimizing biomass particle size and steam activation conditions
A. Villardon,A. Alcazar-Ruiz,F. Dorado,L. Sanchez- Silva
DOI: https://doi.org/10.1016/j.jece.2024.113352
IF: 7.7
2024-06-20
Journal of Environmental Chemical Engineering
Abstract:This research focuses on developing activated biochars for CO 2 adsorption, evaluating the impact of particle size and steam activation conditions on almond shells (AS), pistachio shells (PS), and nut shells (NS), three crops that are grown worldwide. A literature review was carried out on the characteristic parameters that a biomass must have to produce a biochar of an acceptable quality to capture CO 2. Initially, a physicochemical characterization of the selected biomasses was conducted, revealing high levels of volatiles (78–84 wt%), carbon (41–53 wt%), and inherent metals (Ca, K, Mg and Na). This process involved pyrolysis and activation under pre-established conditions, followed by CO 2 adsorption analysis using thermogravimetry. Interestingly, intermediate-sized biochars (ranging from 2 to 1.4 mm) exhibited higher CO 2 uptake. Once the optimal particle size was determined, steam activation conditions were further optimized by varying temperature. In this regard, these conditions were established at 900 °C for 30 min, at a steam flow rate of 0.15 mL/min and a pressure of 1 bar. This study highlighted biomass heterogeneity, resulting in distinct biochar morphologies (microporous PS activated biochars, and mesoporous NS and AS biochars) and higher carbon content compared to raw materials. However, the O/C and H/C ratios fell as severity rose. On researching steam activation holding times at a constant temperature of 900 °C, similar trends were observed, with high carbon content in the biochars. Finally, based on CO 2 adsorption results, 2.81, 2.12 and 1.76 mmol/g for PS, AS and NS activated biochars, respectively, optimal shorter activation times (15 min) were selected for AS and NS biochars.
engineering, chemical, environmental