Abstract:High solid anaerobic digestion (HSAD) achieves the benefits of high volumetric loading rates and lower reject water production, which, however, results in much more concentrated reject water with a remarkable increase in organics and nitrogen compared with that from conventional AD with low solid content. The high concentrations of ammonium (2000-3500 mg/L) and COD (3000-4000 mg/L) were reported to exert inhibition on anammox bacteria (AnAOB), posing challenges to the application of the partial nitritation/anammox (PN/A). To date, no cases of PN/A process start-up for sludge HSAD reject water were reported. This study demonstrated the start-up process of a 480 m3/d PN/A project without anammox sludge inoculation and treating HSAD reject water from a centralized dewatered sludge treatment plant. The project did not construct new infrastructures but utilized previously constructed tanks to upgrade the process from existing short-cut nitrification-denitrification to a two-stage PN/A process. Although no external anammox sludge inoculation was performed to save seeding sludge cost, the start-up was successfully achieved in about 9 months (273 days) based on a three-step method of "AnAOB enrichment - sludge acclimation - capacity doubling". During start-up, the relative abundance of AnAOB (Candidatus_Kuenenia) increased from near zero to 12.0%. After start-up, the total inorganic nitrogen (TIN) removal load reached 0.74 kgN/(m3•d), with a total nitrogen removal efficiency of over 90%. Compared to the traditional nitrification-denitrification process, the PN/A process remarkably reduces the addition of organic chemicals and aeration energy consumption, saving approximately 4.2 million yuan (RMB) in operational costs annually. In summary, this research provides a full-scale reference for the start-up of the PN/A process treating sludge HSAD reject water.

Startup and performance of a novel single-stage partial nitritation/anammox system for reject water treatment

Start Up of Partial Nitritation-Anammox Process Using Intermittently Aerated Sequencing Batch Reactor: Performance and Microbial Community Dynamics.

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

[Nitrite Regulation During Start-up of Combined Partial Nitritation and ANAMMOX Process].

Start-up of single-stage partial nitritation-anammox micro-granules system: Performance and microbial community dynamics

System for startup of partial nitritation - ANAMMOX - denitrification (PNAD) reaction

[Start-Up of a Full-Scale System for Short-Cut Nitrification and Anammox in Treatment of Pharmaceutical Wastewater].

Start-up and optimization of a one-stage partial nitrification-anammox (PN-A) process treating low ammonium concentration wastewater: experimental results and modeling investigation

Successful Startup of One-Stage Partial Nitritation and Anammox System Through Cascade Oxygen Supply and Potential Ecological Network Analysis

The Performance of Anammox Reactor During Start-Up: Enzymes Tell the Story

Performance characteristics and community analysis of a single-stage partial nitritation, anammox and denitratation (SPANADA) integrated process for treating low C/N ratio wastewater

Mathematical simulation and experimental verification of a novel control strategy for a single stage PN/A (partial nitrification/Anammox) SBR (sequencing batch reactor)

Start-up of mainstream anammox process through inoculating nitrification sludge and anammox biofilm: Shift in nitrogen transformation and microorganisms

Start-up, influence factors, and the microbial characteristics of partial nitrification in membrane bioreactor

Rapid start-up of single-stage nitrogen removal using anammox and partial nitritation (SNAP) process in a sequencing batch biofilm reactor (SBBR) inoculated with conventional activated sludge

Start-up of a full-scale two-stage partial nitritation/anammox (PN/A) process treating reject water from high solid anaerobic sludge digestion (HSAD)

Chemical oxygen demand and nitrogen removal from real membrane-manufacturing wastewater by a pilot-scale internal circulation reactor integrated with partial nitritation-anammox

Granulation of nitritation sludges in sequencing batch reactor

Extracellular polymeric substances and microbial community shift during the start‐up of a single‐stage partial nitritation/anammox process

Start-up of PN-anammox system under low inoculation quantity and its restoration after low-loading rate shock

Start-up of SBR Nitritation under Variable Substrate Concentrations