Abstract:A ≥ 200 °C fraction (CT200F) of low-temperature coal tar was prepared by a rotary film evaporator. The catalytic conversion experiments of CT200F and six model compounds were conducted on the pyrolysis gas chromatography–mass spectrometer. The yields of catalytic conversion products benzene, toluene, xylene, and naphthalene (BTXN) were analyzed by semi-quantitative analysis according to the chromatographic peak areas. Additionally, the possible formation pathways and mechanisms of the target products BTXN generated over different catalysts were investigated. The results show that the yield of aromatic hydrocarbons increases and the yield of acid compounds decreases during CT200F pyrolysis over ZSM-5, HY, USY, and β-zeolite compared with that of its non-catalytic pyrolysis, especially the yields of BTXN obtained over USY and β-zeolite increase by 128 and 108%, respectively. The pore structure of ZSM-5 is suitable to produce BTX, while the suitable acidity and pore structure of USY, HY, and β-zeolite are more beneficial for the selective preparation of naphthalene than that of ZSM-5. The conversion pathways of six model compounds into BTXN over zeolites were obtained, and the following conclusions can be drawn: The dehydroxylation effect of zeolites shows the order of ZSM-5 > HY > USY > β-zeolite. The catalytic effect of zeolites on the cracking and ring opening of PAHs in CT200F shows the order of β-zeolite > USY > HY > ZSM-5. The catalytic effect of catalysts on the cracking and aromatization of aliphatic compounds shows the order of ZSM-5 > β-zeolite > USY > HY. β-zeolite has an outstanding catalytic performance in the conversion of PAHs into naphthalene. ZSM-5 and HY can effectively remove phenolic hydroxyl groups in phenol and naphthol. During the catalytic conversion processes of the coal tar fraction and model compounds, the catalytic effect of the pore constructions of zeolites is more important than their acidities, which determines whether large molecules can enter and whether acid sites in non-micropores can be effectively utilized.This article has not yet been cited by other publications.

Ex‐situ catalytic fast pyrolysis of low‐rank coal over HZSM ‐5 and modified Mg/ HZSM ‐5 catalysts

Comparison of non-catalytic and catalytic fast pyrolysis of corncob in a fluidized bed reactor.

In Situ Catalytic Pyrolysis of Low-Rank Coal for the Conversion of Heavy Oils into Light Oils

Catalytic Pyrolysis of Bituminous Coal under Pyrolysis Gas over A Ni/Mgo Catalyst

Online Study on the Catalytic Pyrolysis of Bituminous Coal over HUSY and HZSM-5 with Photoionization Time-of-Flight Mass Spectrometry

In Situ Catalytic Conversion of Biomass Fast Pyrolysis Vapors on HZSM‑5

Effect of Si/Al Ratio of HZSM-5 Zeolites on Catalytic Upgrading of Coal Pyrolysis Volatiles

Study on lightening of coal tar with metal oxide supported γ-Al2O3 catalyst

Catalytic Conversion of a ≥ 200 °C Fraction Separated from Low-Temperature Coal Tar into Light Aromatic Hydrocarbons

Base-acid tandem catalytic upgrading of coal pyrolysis volatiles: the effects of alkaline earth oxides and modified HZSM-5 zeolites

Integrated Process of Coal Fast Pyrolysis in a Fluidized Bed Reactor with Reforming Reaction of Simulated Fuel Gas to Promote Light Tar Evolution

Product Regulation and Catalyst Deactivation During Ex-Situ Catalytic Fast Pyrolysis of Biomass over Nickel-Molybdenum Bimetallic Modified Micro-Mesoporous Zeolites and Clays.

Increasing Light Aromatic Products During Upgrading of Lignite Pyrolysis Vapor over Co-modified HZSM-5

Impact of microporous zeolite-coated macroporous supports on the catalytic pyrolysis of methylcyclohexane under supercritical conditions

Catalytic Fast Pyrolysis of Tar-Rich Coal with a Bauxite Residue for Upgrading High-Value Products: Product Distribution and Kinetic Analysis

Catalytic conversion of coal pyrolysis vapors to light aromatics over hierarchical Y-type zeolites

Effect of Atmosphere and Methane Catalytic Activation on Coal Pyrolysis in Fluidized Bed Reactor

Comparison of the Situ Catalytic Conversion of Biomass Fast Pyrolysis Vapors Using Different Zeolite

Effect of coal ranks on light aromatics production during reforming of pyrolysis volatiles over HZSM-5 under Ar and H2-assisted atmospheres

Fast and catalytic pyrolysis of xylan: Effects of temperature and M/HZSM-5 (M = Fe, Zn) catalysts on pyrolytic products

Catalytic pyrolysis of tar-rich coal for coal tar to light oil with catalysts of modified granulated blast furnace slag