Abstract:This study aimed to investigate whether separating organics depletion from nitrification increases the overall performance of urine nitrification. Separate organics depletion was facilitated with membrane aerated biofilm reactors (MABRs). The high pH and ammonia concentration in stored urine inhibited nitrification in the first stage and therewith allowed the separation of organics depletion from nitrification. An organics removal of 70 % was achieved at organic loading rates in the influent of 3.7 gCOD d-1 m-2. Organics depletion in a continuous flow stirred tank reactor (CSTR) for organics depletion led to ammonia stripping through diffused aeration of up to 13 %. Using an MABR, diffusion into the lumen amounted for 4 % ammonia loss only. In the MABR, headspace volume and therefore ammonia loss through the headspace was negligible. By aerating the downstream MABR for nitrification with the off-gas of the MABR for organics depletion, 96 % of the ammonia stripped in the first stage could be recovered in the second stage, so that the overall ammonia loss was negligibly low. Nitrification of the organics-depleted urine was studied in MABRs, CSTRs, and sequencing batch reactors in fed batch mode (FBRs), the latter two operated with suspended biomass. The experiments demonstrated that upstream organics depletion can double the nitrification rate. In a laboratory-scale MABR, nitrification rates were recorded of up to 830 mgNL-1 d-1 (3.1 gN m-2 d-1) with ambient air and over 1500 mgNL-1 d-1 (6.7 gN m-2 d-1) with oxygen-enriched air. Experiments with a laboratory-scale MABR showed that increasing operational parameters such as pH, recirculation flow, scouring frequency, and oxygen content increased the nitrification rate. The nitrification in the MABR was robust even at high pH setpoints of 6.9 and was robust against process failures arising from operational mistakes. The hydraulic retention time (HRT) required for nitrification was only 1 to 2 days. With the preceding organics depletion, the HRT for our system requires 2 to 3 days in total, whereas a combined activated sludge system requires 4 to 8 days. The N2O concentration in the off-gas increases with increasing nitrification rates; however, the N2O emission factor was 2.8 % on average and independent of nitrification rates. These results indicate that the MABR technology has a high potential for efficient and robust production of ammonium nitrate from source-separated urine.

A single-stage MABR reactor in the post-treatment of poultry slaughterhouse wastewater: nitrogen removal and microbial community

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

Feasibility of A Membrane-Aerated Biofilm Reactor to Achieve Single-Stage Autotrophic Nitrogen Removal Based on Anammox

The membrane aerated biofilm reactor for nitrogen removal of wastewater treatment: Principles, performances, and nitrous oxide emissions

Performance of pilot-scale membrane aerated biofilm reactors integrated with anoxic nano-biotechnological reactor for domestic wastewater treatment

Nitrogen and Carbon Removals from Food Processing Wastewater by an Anoxic/aerobic Membrane Bioreactor

Intensified Partial Nitrification and Microbiome Response in a Membrane Pulsing-Aerated Biofilm Reactor

Mainstream wastewater treatment by polyaluminium ferric chloride (PAFC) flocculation and nitritation-denitritation membrane aerated biofilm reactor (MABR)

Integrated thiosulfate-driven denitrification, partial nitrification and anammox process in membrane-aerated biofilm reactor for low-carbon, energy-efficient biological nitrogen removal

Evaluation of the Combined C/N ratio, DO Set Point, and HRT Influence on Nitrogen Removal Rate in One-Stage Reactor Through Partial Nitrification Anammox Process During Treatment of Synthetic Digestate of Poultry Litter Wastewater

Evaluating the potential of a new reactor configuration to enhance simultaneous organic matter and nitrogen removal in dairy wastewater treatment

Multi-parameter control-based operation strategy for mainstream deammonification in an integrated anaerobic biofilm reactor-step feed MBR

Unraveling microbial characteristics of simultaneous nitrification, denitrification and phosphorus removal in a membrane-aerated biofilm reactor

High-rate nitrogen removal by partial nitritation/anammox with a single-stage membrane-aerated biofilm reactor

Coupling Partial Nitritation, Anammox and n-DAMO in a membrane aerated biofilm reactor for simultaneous dissolved methane and nitrogen removal

A pilot-scale SNAD-MBBR process for treating anaerobic digester liquor of swine wastewater: performance and microbial community

Lumen air pressure regulated multifunctional microbiotas in membrane-aerated biofilm reactors for simultaneous nitrogen removal and antibiotic elimination from aquaculture wastewater

Test of Membrane Aerated Biofilm Reactors for Nitrogen Removal in Wastewater Treatment

The Development of a Novel Hybrid Aerating Membrane-Anaerobic Baffled Reactor for the Simultaneous Nitrogen and Organic Carbon Removal from Wastewater

Aeration strategies and temperature effects on the partial nitritation/anammox process for nitrogen removal: performance and bacterial community assessment

Increasing urine nitrification performance with sequential membrane aerated biofilm reactors