Abstract:The supercritical CO2 Brayton cycle has promising prospects for application in hypersonic vehicles owing to its performance and compactness. However, the extreme thermal environment in aircrafts and limited cold sources make the transient characteristics of the Brayton cycle unclear. In this study, dynamic models of supercritical CO2 Brayton cycle were established. The heat exchanger model was based on the supercritical moving boundary method proposed in our previous work and the finite volume method, whereas the modeling of the turbomachinery was based on the performance map approach. Proportional-integral-derivative (PID) controller modules were introduced to enable closed-loop control of various parameters to meet different working conditions. The transient characteristics of the heat exchanger and Brayton cycle model were validated using literature data. Dynamic models for both simple and recuperated layouts were developed to study the transient behavior in aerospace scenarios with sudden thermal load increases, cold-source limitations, and combined disturbances. Under the given conditions, results indicate that both sudden increases in thermal load and cold-source limitations cause a decrease in the thermodynamic performance, with a reduction in thermal efficiency of 0.7 and 2.2%, respectively. When these conditions were combined, the performance further deteriorated, with the thermal efficiency decreasing from 14.4 to 9.5%. This condition can result in compressor over speeding and failure of the PID controller. The simulation results for the two layouts show that the recuperated layout has a 34.8% higher power output at the cost of increasing the total weight by 29.7%. The dynamic models proposed in this study provide valuable insights into the behavior of Brayton cycle systems in hypersonic vehicles, aiding system design, evaluation, and control strategy development.

Numerical appraisal of the role of heat transfer regimes on transient response of carbon dioxide based supercritical natural circulation loop during power upsurge

Experimental and Numerical Investigation on the Dynamic Characteristics of a Lab-Scale Transcritical CO2 Loop

Flow Dynamics in Transient Heat Transfer of N-Decane at Supercritical Pressure

Study of Trans-Critical CO2 Natural Convective Flow with Unsteady Heat Input and Its Implications on System Control

Flow and Heat Transfer Instability of Supercritical Carbon Dioxide in a Vertical Heated Tube

Effect of heat transfer on the instabilities and transitions of supercritical CO2 flow in a natural circulation loop

Transient Modeling of 10 MW Supercritical CO2 Brayton Power Cycles Using Numerical Propulsion System Simulation (NPSS)

Flow and Heat Transfer Characteristics of Supercritical CO2 in a Natural Circulation Loop

Transient Responses of Turbulent Heat Transfer of Cryogenic Methane at Supercritical Pressures

Numerical Investigation of Thermohydraulic Characteristics in Supercritical CO2 Natural Circulation Loop with Spatially Varying Temperature

Direct Numerical Simulation of Convective Heat Transfer of Supercritical Pressure in a Vertical Tube with Buoyancy and Thermal Acceleration Effects

The Flow Transition Characteristics of Supercritical CO2 Based Closed Natural Circulation Loop (NCL) System

Flow resistance analysis of non-isothermal supercritical CO2

High‐heat Flux Flow and Heat Transfer Transitions in a Supercritical Loop: Numerical Verification and Correlation

Dynamic Simulation and Analysis of Transient Characteristics of a Thermal-to-electrical Conversion System Based on Supercritical CO2 Brayton Cycle in Hypersonic Vehicles

Near-Critical Natural Circulation Flows Inside an Experimental Loop: Stability Map and Heat Transfer

Numerical Investigation of Different Heat Transfer Behaviors of Supercritical CO2 in a Large Vertical Tube

Study on the Stability of Natural Circulation Under Supercritical Pressure

Experimental Study of Trans-Critical and Supercritical Co2 Natural Circulation Flow in A Closed Loop

Thermal and Hydrodynamic Characteristics of Supercritical Co2 Natural Circulation in Closed Loops

Power Rising and Descending Transient for the OTSG of a Small PWR