Abstract:The transition mechanism is of significance to the corrosion behavior of zirconium alloys. Two important phenomena may be the causes of transition, which are the undulated wavy interface and the existence of tetragonal zirconia at the metal/oxide interface. There is little detailed study on the correlation between these two features. Micro-scale Raman imaging of intensity and Raman shifts was conducted in this study to further evaluate the connection. It was studied based on the oxide films formed on Zr-0.5Sn-0.15Nb-0.5Fe-0.2 V and N36 claddings corroded in 500 degrees C/10.3 MPa steam. The stress in interfacial tetragonal zirconia has relationship with the amplitude to wavelength ratio of the undulated part and it is always found to be larger at the convex parts of interface. These parts are prone to crack formation. At one convex position that the oxide cracked, t-ZrO2 is found to be preserved beneath and above the crack. Stress is also preserved, but partially released. When interfacial t-ZrO2 exists, the stress in the surrounding monoclinic phase is observed to be small. This provides us a more detailed figure of the stress distribution in oxide film. Tetragonal phase is mainly distributed near the metal/oxide interface. More intense tetragonal signals are frequently found at the convex positions of interface. This might result from large tetragonal grains or aggregation of small t-ZrO2 grains. These grains are stabilized at convex parts because of the large compressive stress and might be unstable once the grain size exceeds a critical value or once cracks are formed at such positions. An illustration of the connection between t-ZrO2 and undulated interface is then proposed. Possible reasons that facilitate the formation of lateral cracks and possible reasons for the existence of t-ZrO2 at the convex positions are discussed. (C) 2019 Elsevier B.V. All rights reserved.

The formation of atomic and sub-nano scale pores under tensile strain in oxide films on Zr alloys: A first-principles study

Effects of Zr Addition on the Deformation Behavior, Microstructure and Mechanical Properties of Dental Ti Alloys

The first-principles calculations for the elastic properties of Zr2Al under compression

Strengthening Mechanism of Ω-Zr

The Correlation Between Tetragonal Phase and the Undulated Metal/oxide Interface in the Oxide Films of Zirconium Alloys

Exploring the stability, thermodynamic and mechanical properties of zirconium oxides and suboxides under temperature and pressure: A first-principles predictions

Study on corrosion and wear behavior mechanism of Zr-based bulk amorphous

Three-dimensional atomic interface between metal and oxide in Zr-ZrO2 nanoparticles

3D reconstruction and interconnectivity quantification of the nano-porosity in the oxide layer of corroded Zr alloys

Three-dimensional atomic insights into the metal-oxide interface in Zr-ZrO2 nanoparticles

Research on the Existence and Stability of Interfacial Tetragonal Zirconia Formed on Zirconium Alloys

Unraveling Different Influences of the Fraction of the Tetragonal Phase in Oxide Films on the Corrosion Resistance of Zr Alloys from the Phase Transition Mechanism

Unraveling different influences of the fraction of tetragonal phase in oxide film on corrosion resistance of Zr alloys from phase transition mechanism

First-principles study on stability, adhesion and fracture properties of ZrO2/W interface in composite materials

Investigation on corrosion behavior of Zr-bearing TA10-based titanium alloys

Critical behavior of interfacial t-ZrO2 and other oxide features of zirconium alloy reaching critical transition condition

Formation, control and functionalization of nanoporous zinc by selective corrosion of Al–Zn alloys with varying compositions

Size dependent mechanical properties and deformation mechanisms in Ti and Zr films

Excellent Corrosion and Wear Resistance of Amorphous and Crystalline ZrCoAl Alloys

Design of amorphous-nanocrystalline films of TiAlCrNbZr x multi-component alloy: The effect of Zr on the corrosion resistance and mechanical properties

Strain and Support Effects on Phase Transition and Surface Reactivity of Ultrathin ZnO Films: DFT Insights