Abstract:Friction is a primary failure mode in micro-nano electromechanical systems due to the high surface-to-volume ratio. Microgravity further complicates this issue in journal-bearing-like conformal contacts by promoting irregular disturbances. This paper aims to gain insights into the anti-friction design of journal-bearing-like devices through molecular dynamics simulation. A molecular dynamics model was proposed and the calculation method of the friction force was derived. In the absence of disturbance, the proposed model was compared with a non-conformal model which unfolded the bearing as a plane, and the influence of initial radial clearance and axis inclination on the friction force was investigated. The results showed that the proposed model could present more accurate friction forces than the non-conformal model. The friction force was inversely proportional to the initial clearance, and the axis inclination could reduce the friction force. Regarding disturbances as the superposition of two vibrations perpendicular to each other, in which case the trajectory of the journal was a Lissajous curve, the effects of frequency, stiffness coefficient, amplitude ratio, and frequency ratio were investigated. The results showed that the average friction force increased with the rising frequency in the range of 0.8 ~ 4.8 GHz, then decreased with the further increase of frequency. The average friction force was lowered when the stiffness coefficient increased from 100N/m to 1000N/m. For two representative frequencies, the average friction force exhibited different trends with the amplitude ratio. Except for the case of 1.25, increasing the frequency ratio could reduce the friction force. It seemed that applying a well-designed Lissajous route was a promising way to reduce friction.

Negative differential friction coefficients of two-dimensional commensurate contacts dominated by electronic phase transition

Negative Friction Coefficient in Microscale Graphite/mica Layered Heterojunctions

Positive-Negative Tunable Coefficients of Friction in Superlubric Contacts

Strain Tuning on Van Der Waals Negative Capacitance Transistors

Control of interlayer friction in two-dimensional ferromagnetic CrBr3

Negative thermal expansion induced suppression of wear in dry sliding friction

Negative or Positive? Loading Area Dependent Correlation Between Friction and Normal Load in Structural Superlubricity

Chemifriction and Superlubricity: Friends or Foes?

3D-printed biomimetic surface structures with abnormal friction properties

Theoretical Proposal and Material Realization of Ferromagnetic Negative Charge-Transfer Energy Insulator

Transforming friction: unveiling sliding-induced phase transitions in CVD-grown WS2 monolayers under single-asperity sliding nanocontacts

Dynamical Negative Differential Resistance in Antiferromagnetically Coupled Few-Atom Spin-Chains

Adhesion-dependent Negative Friction Coefficient on Chemically Modified Graphite at the Nanoscale

Charge Density Evolution Governing Interfacial Friction

Atomic simulations of effects of contact size and interfacial interaction strength on superlubricity in incommensurate sliding interface

In-Plane Potential Gradient Induces Low Frictional Energy Dissipation During The Stick-Slip Sliding On The Surfaces Of 2d Materials

Superlubricity Enabled by Load‐Driven Redistribution of Electrons

Frictional Adhesive Contact of Multiferroic Coatings Based on the Hybrid Element Method

Polaronic Contributions to Friction in a Manganite Thin Film

Origin of Friction in Superlubric Graphite Contacts

Friction Properties of Journal-bearing-like Conformal Contacts in Microgravity Environment