Abstract:The capture and sequestration of CO2 generated from large-scale stationary power plants is considered to be one of the leading technologies that could potentially have a significant impact on reducing greenhouse emissions. Among these emerging technologies, the oxy-fuel combustion is a near-zero emission technology that can be adapted to both new and existing pulverized coal-fired power stations. The goal of this work is to make a comparative study on char structural characteristics (including char yield, swelling ratio, BET surface area, pore distribution, morphology) and reactivity during conventional air and oxy-fuel combustion. Specific experimental designs include two series. One is carried out in pure N-2 and CO2 (pyrolysis experiments), and another is prepared in N-2+5%O-2 and CO2+5%O-2. Coal samples included raw coal, low density fraction coal and medium density fraction coal in all experiments. The present study is a further effort to extend our knowledge about physical and chemical structural characteristics and reactivity of char in the presence of high concentration CO2. Combustion and pyrolysis of a density fractionated China coal at drop tube furnace yielded the following conclusions. Compared to oxy-chars obtained under pure CO2 atmosphere, the swelling ratios of char obtained in pure N-2 atmosphere are higher. When adding 5% O-2, experimental results are completely different with those of the pyrolysis experiment. In comparison with the oxy-chars obtained under CO2 + 5%O-2 atmosphere, the swelling ratios of the char obtained in N-2 + 5%O-2 atmosphere are lower. In the pyrolysis experiment, the BET surfaces Area of the oxy-chars are about ten to twenty times as much as chars. When adding 5% O-2, the BET surfaces Area of the oxy-chars are about two to four times as much as chars. During pyrolysis experiment, the total pore volumes of the oxy-chars obtained under pure CO2 are larger in comparison with chars obtained in pure N-2. The pore distributions of the oxy-chars are mainly mesopore and the chars have macropore mostly. The micropore and mesopore volume of oxy-chars are about ten times as much as chars separately and the macropore volume of oxy-chars are about two times as much as chars. When adding 5% O-2, the total pore volumes of the oxy-chars obtained under CO2 + 5%O-2 are also larger in comparison with chars obtained in N-2 + 5%O-2. In the pyrolysis experiment, the reactivity indexes of oxy-chars obtained under pure CO2 are lower in comparison with chars obtained in pure N-2. When adding 5% O-2, no significant differences can be observed, which may be due to the ordering of carbon microcrystalline structure. In pure CO2 atmosphere, the oxy-chars have a highly order polycrystalline structure, but chars obtained at pure N-2 atmosphere have a highly disordered carbonaceous structure.

Structure evolution of lignite char in step pyrolysis and its combustion reactivity

Functional groups evolvement and charcoal formation during lignin pyrolysis/carbonization

Assessment of the Impact of Pyrolysis Conditions on Char Reactivity Through Orthogonal Experimental-Based Grey Relational Analysis

Char Structural Evolution During Pyrolysis and Its Influence on Combustion Reactivity in Air and Oxy-Fuel Conditions

Evolution of the char structure of lignite under heat treatment and its influences on combustion reactivity

Study on the Effect of Pyrolysis Conditions on the Combustion Behavior and Char Structure Evolution.

Structure and combustion reactivity of coal char pyrolyzed in different atmospheres

EFFECT OF PYROLYSIS CONDITIONS ON THE STRUCTURE AND GASIFICATION REACTIVITY OF CHAR

Studying Effects of Solid Structure Evolution on Gasification Reactivity of Coal Chars by In-Situ Raman Spectroscopy

Morphological Characteristics of Chars Obtained from Low-Temperature Pyrolysis of Pulverized Lignite

Characteristics of Chars Prepared by Low-Temperature Co-Pyrolysis of Lignite and Biomass

XRD and Raman characterization of microstructure changes of char during pyrolysis

Structural evolution characteristics of lignite during pyrolysis based on alkaline-oxygen oxidation, NMR and FTIR

Effect of microstructure of rapid pyrolysis char on its gasification reactivity

Evolution of char's physical and chemical structure during biomass pyrolysis

Comparison Of Char Structural Characteristics And Reactivity During Conventional Air And Oxy-Fuel Combustion

Relationships Between Char Reactivity and Char Structure from a Suite of Organic Model Compounds

Influences of Carbon Structure on the Reactivities of Lignite Char Reacting with CO2 and NO

Effect of Temperature on Lu’an Bituminous Char Structure Evolution in Pyrolysis and Combustion

Effect of Pyrolysis Intensity on the Reactivity of Coal Char

Effect of Microstructures on Char Combustion Reactivity