Abstract:The behavior of the droplet and the film thickness and temperature distribution of liquid film are critical to heat and mass transfer performance, especially for discontinuous droplet mode. A 3D model was established to capture and illustrate the transient and discontinuous regularity of evolution of droplets. Discontinuous droplet formation and growth account for the majority of the droplet motion cycle, approximately 45-65%. A perceived opposite flow field evolution law was found, where the evolution of the liquid film spreading distance, velocity, and film thickness patterns triggered by the impact of a single discontinuous droplet does not change with the flow rate. The flow rate affected only the flow evolution pattern by modulating the spacing of the discontinuous droplets produced, which decreased with an increasing flow rate. In addition, the typical features of transient droplet behavior such as formation, growth, breakup, detachment, impact and ripple, and fluctuation of spreading film were fully revealed. The corresponding transient characteristics of the spreading distance, velocity, film thickness, and temperature distribution were also formulated. After impact, the velocity of the spreading film started to increase rapidly and then decrease slowly, which could reach a maximum of about 0.6-0.7 m s(-1) within 20 ms. There were two different transient thickness zones: the rapid spreading zone and the stability zone, which showed a sharp increase at a height of about 2000 mu m within 10 ms after the droplet impact and then gradually decreased as the film spread. In addition, the temperature distribution and local evolution regularity mechanism were systematically analyzed, the local high-temperature zone was detected, and its internal formation mechanism was also revealed.

Droplet Detachment from a Vertical Filament with One End Clamped

Dynamic Buckling of a Filament Impacted by a Falling Droplet.

Droplet detachment and bead formation in visco-elastic fluids

Plethora of transitions during breakup of liquid filaments

Weakly Charged Droplets Fundamentally Change Impact Dynamics on Flat Surfaces

Wetting and wrapping of a floating droplet by a thin elastic filament

Impact Dynamics of a Droplet on Superhydrophobic Cylinders Structured with a Macro Ridge

Breakup Dynamics of Elastic Droplet and Stretching of Polymeric Filament in a T-junction

General Predictive Framework for Droplet Detachment Force

Droplet impact on a superhydrophobic solid substrate with a superhydrophilic annulus

Dynamics of a viscoelastic liquid filament connected to two mobile droplets

Air Film Evolution During Droplet Impact Onto a Solid Surface

Critical condition for electrowetting-induced detachment of a droplet from a curved surface

Dynamics of Finite-Size Air Filaments in a Static Liquid

Discontinuous and Transient Behavior Evolutionary Laws of Flow and Temperature Characteristics of Droplet Mode over a Horizontal Tube Falling Film

Hydrodynamic Analysis of the Energy Dissipation of Droplets on Vibrating Superhydrophobic Surfaces

Dynamics of Droplet-Film Collision

Unsteady Sheet Fragmentation: Droplet Sizes and Speeds

Hydrodynamics and Morphologies of Droplet Coalescence

The falling, necking, and break-up of droplet between horizontal tubes with low Reynolds number

Bouncing Drop on Liquid Film: Dynamics of Interfacial Gas Layer