Abstract:Many practical lean-premixed combustion systems involved in land-based power plants, gas turbines and boilers are susceptible to self-excited combustion instability, which is characterized by detrimental periodic pressure oscillations. Little attention has been paid on experimentally characterizing the chemical emissions and thermodynamic properties of a thermoacoustic swirl combustor. In this work, the effects of (1) fuel-air equivalence ratio Phi and fuel flow rate Q(CH4) on generating such combustion instability and its impact on chemical emissions and thermodynamic properties in a swirling combustor are experimentally studied. For this, a methane-fueled lab-scale swirl combustor is designed and tested. To monitor the thermodynamic properties of the combustor, an acoustic pressure sensor, an infrared thermal imaging camera, K-type thermal couples, and an infrared flue gas analyzer are applied. It is found that the fuel-air ratio plays an important role on generating combustion instability at different frequencies and amplitudes. This is confirmed by conducting autocorrelation and frequency spectrum analyses of the acoustic pressure time trace. Furthermore, the dominant mode swap (mode-switching) between a low frequency omega(1) and a high non-harmonic one is experimentally observed. Whether the mode switching from high (harmonic or non-harmonic) to low frequency or low to high frequency is found to depend strongly on Q(CH4). As the equivalence ratio is changed from lean to rich, i.e. 0.8 <= Phi <= 1.2, NOx emission is increased from 1 ppm to 37 ppm. However, CO emission is decreased by 2 order of magnitudes from 1000 ppm first and then increased. The minimum CO emission is approximately 3.0 ppm. In addition, O-2 concentration is decreased by more than 80% with increased Phi, depending on the methane flow rate. This means that the combustion efficiency characterized by the O-2 emission is decreased dramatically from 99.5% to 68% with Phi increased from 0.6 to 1.2. The present work sheds light on the characteristics of chemical emissions and thermodynamic properties, when a thermoacoustic swirl combustor is operated with methane-air equivalence ratio Phi varied from lean to rich condition and different Q(CH4). It opens up a practical means to design a stably operated but low-emission thermoacoustic swirl combustor.

Investigation of Flame Response in a Swirling Micromix Hydrogen-Methane Combustor

Investigation of Longitudinal Self-Excited Combustion Instability in a Micromix Hydrogen Combustor

Numerical Investigation of the Combustion and Thermoacoustic Characteristics in an Annular Combustor with Hydrogen

Experimental investigation on macrostructure and evolution of hydrogen-air micro-mix multi-jet flames

Effects of flow-flame interactions on the stabilization of ultra-lean swirling CH<sub>4</sub>/H<sub>2</sub>/air flames

The effect of hydrogen enrichment on the forced response of CH4/H2/Air laminar flames

Flame visualization and spectral analysis of combustion instability in a premixed methane/air-fueled micro-combustor

Effect of High Hydrogen Enrichment on the Outer-Shear-layer Flame of Confined Lean Premixed CH4/H2/air Swirl Flames

EFFECT OF HYDROGEN AND AMMONIA ADDITION ON SELF-EXCITED THERMOACOUSTIC INSTABILITIES OF PARTIALLY PREMIXED METHANE/AIR FLAMES

Response of Lean Premixed Swirl Tubular Flame to Acoustic Perturbations

Experimental Study on Structure and Blow-Off Characteristics of NH 3/CH 4 Co-Firing Flames in a Swirl Combustor

The turbulent flame structure in a steam diluted H 2 /Air micromix flame

Flame Characteristics of Methane/air with Hydrogen Addition in the Micro Confined Combustion Space

Study of Burner Geometry Effects on Non-Premixed Flame Response under Acoustic Excitation

Study of turbulent flame characteristics of water vapor diluted hydrogen-air micro-mixing combustion

Flame Stability and NOx Emission Characteristics of a High H2-content CH4/H2 Fueled Micro-Mixing Burner

Experimental Characterizing Combustion Emissions and Thermodynamic Properties of a Thermoacoustic Swirl Combustor

Experimental study of flame evolution, frequency and oscillation characteristics of steam diluted micro-mixing hydrogen flame

Investigation of turbulent premixed methane/air and hydrogen-enriched methane/air flames in a laboratory-scale gas turbine model combustor

Experimental Investigation of Methane Premixed Swirling Flame Dynamics

Experimental investigation of the characteristics of combustion in the full hydrogen blending range of methane-hydrogen mixtures in a MILD model combustor