Abstract:It is well-known that the -70 degrees C ultra-low temperature freezers have been widely concerned for vaccine and biomedical products storage due to the outbreak of COVID-19. This paper carries out the experimental investigation on performance characteristics of a -70 degrees C ultra-low temperature medical freezer with single-stage Joule-Thomson refrigeration system by using binary hydrocarbon mixture R601a/R1150 and ternary mixture R601a/R290/R1150. The aim is to explore and verify hydrocarbon refrigerants that can achieve lower energy consumption, thereby providing a scientific basis for the optimization of ultra-low temperature medical freezers. The experimental results show that both R601a/R1150 and R601a/R290/R1150 with a charge of 250 g could achieve the refrigeration temperature below -70 degrees C in a 568 L large volume vertical freezer. Comparing binary with ternary refrigerants, it is found that the addition of medium-boiling component R290 is beneficial to reduce the daily energy consumption. When the mass fraction of R601a/R1150 is 0.70/0.30, the lowest daily energy consumption for -70 degrees C is 9.06 kW h & sdot;24 h-1. When the mass fraction of the R601a/R290/R1150 is 0.70/0.10/ 0.20, the daily energy consumption is 8.42 kW h & sdot;24 h-1, which is 7.06 % lower than that when using the R601a/ R1150. This indicates that careful selection of refrigerant components and composition optimization can lead to substantial energy savings. Furthermore, it is also observed that among these three components, the low-boiling component R1150 has the most significant influence on the system pressures and operating power, followed by R601a and R290.

Experimental Study on Performance Characteristics of a -70 °C Ultra-Low Temperature Medical Freezer with Mixed Hydrocarbon Refrigerant

Theoretical Investigation on the Performance of a Modified Refrigeration Cycle Using Binary Zeotropic Hydrocarbon Mixture R170/R290

Experimental Study on an Absorption Refrigeration System at Low Temperatures

Numerical investigations on the performance of a single-stage auto-cascade refrigerator operating with two vapor-liquid separators and environmentally benign binary refrigerants

Study on the Performance of a Novel Waste Heat Recovery System at Low Temperatures

Performance Evaluation of an Ejector Subcooling Refrigeration Cycle with Zeotropic Mixture R290/R170 for Low-Temperature Freezer Applications

Theoretical investigation on an ejector–expansion refrigeration cycle using zeotropic mixture R290/R600a for applications in domestic refrigerator/freezers

Performance Analysis of a Modified Zeotropic Mixture (R290/R600) Refrigeration Cycle with Internal Subcooler for Freezer Applications

Utilization of Ultra-Low Temperature Heat by a Novel Cascade Refrigeration System with Environmentally-Friendly Refrigerants

Experimental investigation of a bypass two-circuit cycle refrigerator-freezer with low GWP zeotropic refrigerants

Analyses of an Improved Double-Absorber Absorption Refrigeration System at Low Temperatures

EXPERIMENTAL STUDY ON A NEW ABSORPTION REFRIGERATION SYSTEM USING R134a+R32/DMF

EXPERIMENTAL STUDY ON A NEW ABSORPTION REFRIGERATION SYSTEM USING R134a+R32/DMF 1

Performance of a Single-Stage Linde-Hampson Refrigerator Operating with Binary Refrigerants at the Temperature Level of −60 °C

Theoretical Study on a Modified Single‐stage Autocascade Refrigeration Cycle with Auxiliary Phase Separator

Performance Evaluation of a Modified Refrigeration Cycle with Parallel Compression for Refrigerator-Freezer Applications

Performance Analysis of an Advanced Ejector-Expansion Autocascade Refrigeration Cycle

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Experimental study of ternary mixture R32/R125/R161 as alternative refrigerant to R407C

OPTIMIZATION OF THE PERFORMANCE OF AN AUTO-CASCADE REFRIGERATOR WITH A LIQUID-GAS SEPARATOR USING ENVIRONMENTALLY BENIGN BINARY REFRIGERANTS

A Numerical Investigation of A Diffusion Absorption Refrigerator Operating with the Binary Refrigerant for Low Temperature Applications