Abstract:With types of in-house-synthesized multi-walled carbon nanotubes (CNTs) and the nitrates of the corresponding metallic components, highly active CNT-promoted Cu–ZnO–Al2O3 catalysts, symbolized as CuiZnjAlk-x%CNTs, were prepared by the co-precipitation method. Their catalytic performance for methanol synthesis from H2/CO/CO2 was studied and compared with the corresponding CNT-free co-precipitated catalyst, CuiZnjAlk. It was shown experimentally that appropriate incorporation of a minor amount of the CNTs into the CuiZnjAlk could significantly increase the catalyst activity for methanol synthesis. Under the reaction conditions of 493 K, 5.0 MPa, H2/CO/CO2/N2 = 62/30/5/3 (v/v), GHSV = 8000 h-1, the observed CO conversion and methanol formation rate over a co-precipitated catalyst of Cu6Zn3Al1-12.5%CNTs reached 36.8% and 0.291 μmol CH3OH s-1 (m2-surf. Cu)-1, which was about 44 and 25% higher than those (25.5% and 0.233 μmol CH3OH s-1 (m2-surf. Cu)-1) over the corresponding CNT-free co-precipitated catalyst, Cu6Zn3Al1. Addition of a minor amount (10–15 wt%) of the CNTs to the Cu6Zn3Al1 catalyst was found to considerably increase specific surface area, especially Cu surface area of the catalyst. H2-TPD measurements revealed that the CNTs and the pre-reduced CNT-promoted catalyst systems could reversibly adsorb and store a considerably greater amount of hydrogen under atmospheric pressure at temperatures ranging from room temperature to ∼573 K. This unique feature would be beneficial for generating microenvironments with higher stationary-state concentration of active hydrogen adspecies on the surface of the functioning catalyst, especially at the interphasial active sites since the highly conductive CNTs might promote hydrogen spillover from the Cu sites to the Cu/Zn interphasial active sites, and thus be favorable for increasing the rate of the CO hydrogenation reactions. Alternatively, the operation temperature for methanol synthesis over the CNT-promoted catalysts can be 15–20 degrees lower than that over the corresponding CNT-free contrast system. This would contribute considerably to an increase in equilibrium CO conversion and CH3OH yield. The results of the present work indicated that the CNTs could serve as an excellent promoter.

Carbon Nanotube and Copper Phyllosilicate Hierarchically Integrated Catalyst for the Efficient Hydrogenation of Ethylene Carbonate to Methanol and Ethylene Glycol

A Cu2o-Derived Polymeric Carbon Nitride Heterostructured Catalyst For The Electrochemical Reduction Of Carbon Dioxide To Ethylene

Size‐dependent Copper Nanoparticles Supported on Carbon Nanotubes with Balanced Cu+ and Cu0 Dual Sites for the Selective Hydrogenation of Ethylene Carbonate

Highly Efficient Ag-modified Copper Phyllosilicate Nanotube: Preparation by Co-Ammonia Evaporation Hydrothermal Method and Application in the Selective Hydrogenation of Carbonate

Copper phyllosilicate-derived ultrafine copper nanoparticles with plenty of Cu<SUP>0</SUP> and Cu<SUP>+</SUP> for the enhanced catalytic performance of ethylene carbonate hydrogenation to methanol

Copper-Based Catalysts Confined in Carbon Nanocage Reactors for Condensed Ester Hydrogenation: Tuning Copper Species by Confined SiO 2 and Methanol Resistance

Long Carbon Nanotubes Intercrossed Cu/Zn/Al/Zr Catalyst for CO/CO2 Hydrogenation to Methanol/dimethyl Ether

Efficient Hydrogenation of Dimethyl Oxalate to Ethylene Glycol Via Nickel Stabilized Copper Catalysts

Heterogeneous selective hydrogenation of ethylene carbonate to methanol and ethylene glycol over a copper chromite nanocatalyst.

Ultra-stable Cu-based catalyst for dimethyl oxalate hydrogenation to ethylene glycol

Efficient Tuning of Surface Copper Species of Cu/SiO2 Catalyst for Hydrogenation of Dimethyl Oxalate to Ethylene Glycol

High-performance copper-based catalysts for ethylene glycol and ethanol synthesis via ester hydrogenation reactions

Highly Active and Selective Copper-Containing Hms Catalyst in the Hydrogenation of Dimethyl Oxalate to Ethylene Glycol

Insight into the Synergism Between Copper Species and Surface Defects Influenced by Copper Content over Copper/Ceria Catalysts for the Hydrogenation of Carbonate

A Cu2 O-derived Polymeric Carbon Nitride Heterostructured Catalyst for the Electrochemical Reduction of Carbon Dioxide to Ethylene

Copper nanoparticles encapsulated in zeolite 13X for highly selective hydrogenation of CO 2 to methanol

Towards understanding the reaction network in the hydrogenation of CO 2 -derived ethylene carbonate

Tailoring the Hydrophobic Interface of Core–Shell HKUST‐1@Cu2O Nanocomposites for Efficiently Selective CO2 Electroreduction

Highly Active CNT-Promoted Cu–ZnO–Al2O3 Catalyst for Methanol Synthesis from H2/CO/CO2

Boosting CO2 electrocatalytic reduction to ethylene via hydrogen-assisted C-C coupling on Cu2O catalysts modified with Pd nanoparticles

Efficient production of methanol and diols via the hydrogenation of cyclic carbonates using copper–silica nanocomposite catalysts