Abstract:Adsorbent is one of the most important factors for separation efficiency in fixed-bed purification techniques. The adsorption behavior of catechins and caffeine onto polyvinylpolypyrrolidone (PVPP) was investigated by static adsorption tests. The results showed that catechins rather than caffeine were preferred to adsorb onto PVPP since the adsorption selectivity coefficient of total catechins vs caffeine was around 22.5, and that adsorption of catechins could be described by the pseudo-second-order model. Adsorption amount of caffeine onto PVPP in green tea extracts solution was much higher than that in purified caffeine solution although the initial concentration of caffeine was similar in the two solutions, indicating the caffeine might be attached with catechins which were adsorbed by PVPP instead of being adsorbed by PVPP directly. The results also showed that the adsorption capacity of catechins and caffeine decreased with an increase in temperature, and that Freundlich and Langmuir models were both suitable for describing the isothermal adsorption of catechins, but not suitable for caffeine. The predicted maximum monolayer adsorption capacity of total catechins by PVPP was 671.77 mg g(-1) at 20 °C, which was significantly higher than that by other reported adsorbents. The thermodynamics analyses indicated that the adsorption of catechins onto PVPP was a spontaneous and exothermic physisorption process, revealing lower temperature was favorable for the adsorption of catechins. Elution tests showed that the desorption rates of catechins and caffeine were higher than 91% and 99% after two elution stages; in detail, almost all of the caffeine could be washed down at the water eluting stage, while catechins could be recovered at the dimethyl sulfoxide/ethanol solution eluting stage. Thus, the PVPP could be used as an excellent alternative adsorbent candidate for separating catechins from crude tea extracts, although some investigations, such as exploring the new eluants with low boiling point and high desorption efficiency, should be conducted furthermore.

Advanced Characterization of Polyphenol Fixed-Bed Adsorption Kinetics Applying Flow-Injection Online Analysis

Fixed-bed adsorption kinetics study of plant total flavonoids based on a flow-injection online spectrophotometric method

Precise evaluation of batch adsorption kinetics of plant total polyphenols based on a flow-injection online spectrophotometric method

Simulation of Levulinic Acid Adsorption in Packed Beds Using Parallel Pore/Surface Diffusion Model

High-throughput screening methods for protein adsorption evaluation with microtiter filter plate

Batch adsorption kinetic and thermodynamic studies of flavonoids from Dracocephalum Moldavia via flow injection online measurement

Adsorption equilibrium, kinetics, and dynamic process of polyphenols from orange peel extract on mixed‐mode adsorption resin HD‐1

Rapid Process Development of Chromatographic Process Using Direct Analysis in Real Time Mass Spectrometry As a Process Analytical Technology Tool

Adsorption Behavior of the Catechins and Caffeine Onto Polyvinylpolypyrrolidone.

A Comparative Study of Using In-Line Near-Infrared Spectra, Ultraviolet Spectra and Fused Spectra to Monitor Panax Notoginseng Adsorption Process.

Characterization of P-nitrophenol adsorption kinetic properties in batch and fixed bed adsorbers

On the Adsorption Capability of Powder Activated Carbon for Phenol

Competitive Adsorption of Phenolic Compounds Onto Activated Carbon Fibers in Fixed Bed

Application of an effective method in predicting breakthrough curves of fixed-bed adsorption onto resin adsorbent

Adsorption characteristics of phenolic compounds onto a new hypercrosslinked polymeric resin containing the 2-carbonylbenzoyl group (ZH-01)

Highly selective adsorption of 5-hydroxymethylfurfural from multicomponent mixture by simple pH controlled in batch and fixed-bed column studies: Competitive isotherms, kinetic and breakthrough curves simulation

A mass transfer model for the fixed-bed adsorption of ferulic acid onto a polymeric resin: axial dispersion and intraparticle diffusion

An automated method of on-line extraction coupled with flow injection and capillary electrophoresis for phytochemical analysis.

Adsorption and Desorption of Phenol on Activated Carbon Fibers in A Fixed Bed

FI-Online Enzymatic Oxidation and Preconcentration by PVA Modified Membranous Capillary-Photometric Determination of Total Phenols in Water

Fast Adsorption Kinetics of CO2 on Solid Amine Sorbent Measured Using Microfluidized Bed Thermogravimetric Analysis