Abstract:Under the background of energy conservation and emission reduction in the aviation industry, blends of ethanol with aviation kerosene have been widely accepted as a potential alternative fuel. Investigating its evaporation process is essential for comprehensively understanding the mechanisms of spray combustion process, which provides significant insights for improving the utilization of aviation fuel. Therefore, in this study, the effects of initial droplet size, ambient temperature and pressure on the micro-explosion and evaporation characteristics of RP70E30 droplets (70% RP-3 aviation kerosene and 30% ethanol by mass) are experimentally investigated. The evolutions of droplet temperature and size are simultaneously obtained by a suspended thermocouple and a highspeed video camera. The results indicate that in the cases without micro-explosion, RP70E30 droplet evaporation undergoes two stages, namely: transient heating and equilibrium evaporation stages. While the evaporation process of RP70E30 droplet with micro-explosion could be separated into three stages: transient heating, fluctuation evaporation and equilibrium evaporation stages. The sequential order of fluctuation evaporation stage and equilibrium evaporation stage is determined by the occurrence time of micro-explosion. RP70E30 droplets only exhibit weak rupture phenomena: weak micro-explosion and puffing. For all test conditions, a continuous increase in droplet temperature is observed throughout the entire evaporation process, and its trend exhibits a three-stage characteristic, including a rapid rise, a slow rise and then another rapid rise stages. At 400 degrees C and 1 bar, increasing initial droplet diameter (from 0.746 to 1.258 mm) can promote the heating and evaporation of RP70E30 droplet. While at 1 bar and 600 degrees C, the droplet with an initial diameter of 1.156 mm evaporates at a slower rate than droplet with an initial diameter of 1.030 mm in the early evaporation process. This is because weak micro-explosion somewhat suppresses the evaporation of PR70E30 droplet, which is attributed to the formation of bubbles increasing the heat transfer resistance inside the droplet. The droplets having similar initial diameters (from 0.95 to 1.05 mm) were selected to investigate the effects of ambient pressure and temperature on evaporation. At all the studied temperatures (400-600 degrees C) and pressures (1-20 bar), increasing ambient pressure and temperature both have a promoting effect on the heating and evaporation of RP70E30 droplet. Moreover, at 1 bar, high temperature can increase the possibility of micro-explosion. At 5-20 bar, no microexplosion occurs.

Experimental Study on Evaporation Characteristics of Methyl Oleate Droplet Across Critical Pressure and Temperature Environments

Measurement of Interacting Ethanol Droplets Evaporation at Moderately Elevated Temperature and Pressure Using Phase Rainbow Refractometry

Experimental Investigation of Evaporation Dynamic of Sessile Droplets in Pure Vapor Environment with Low Pressures

Numerical Simulation of the Evaporation Characteristics of a Dimethyl Ether Droplet in Supercritical Environment

Experimental investigation on evaporation characteristics of RP-3 aviation kerosene droplet above the critical temperature under various pressure conditions

Experimental and Theoretical Investigation on Rapid Evaporation of Ethanol Droplets and Kerosene Droplets During Depressurization

Experimental Investigation on Evaporation and Micro-Explosion Characteristics of Ethanol/rp-3 Aviation Kerosene Blend Droplets at Elevated Pressures and Temperatures

Experimental Investigation Evaporation Of Liquid Mixture Droplets During Depressurization And Into Air Stream

Numerical investigation on the coupling effect of sessile ethanol droplet evaporation and the induced thermal flow in its pure vapor environment at low pressure

Experimental Investigation on Evaporation of a Single Droplet Levitated in Acoustic Field

Experimental and Theoretical Investigation of Contact-Angle Variation for Water–ethanol Mixture Droplets on a Low-Surface-energy Solid

Molecular Dynamics Simulations of the Evaporation Process of a Fuel Droplet Under Supercritical Environment

The investigation of evaporation behavior of lubricating oil droplet at high ambient temperature

Evaporation Kinetics of Sessile Water Droplets on a Smooth Stainless Steel Surface at Elevated Temperatures and Pressures

Evaporation and Combustion Characteristics of Hydrocarbon Fuel Droplet in Sub- and Super-Critical Environments

Evaluation of droplet evaporation characteristics and its influencing factors in high-temperature gaseous environment

Experimental Study of the Effect of the Initial Droplet Diameter on the Evaporation Characteristics of Unsymmetrical Dimethylhydrazine Droplets in a Subcritical Environment

Experimental and Numerical Investigations on Flash Evaporation of a Sessile Droplet under Reduced Pressure

Evaporation Characteristics of Cis-1,1,1,4,4,4-hexafluoro-2-butene (r1336mzz(z)) Droplet in High Pressure and Temperature Environments

Molecular dynamics study on the interfacial characteristics in the process of sub/supercritical evaporation

Fuel Droplet Evaporation in Sub-Critical and Super-Critical Pressure Environments