Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Numerical investigation on the coupling effect of sessile ethanol droplet evaporation and the induced thermal flow in its pure vapor environment at low pressure

Numerical investigation on flow instability of sessile ethanol droplets evaporating in its pure vapor at low pressure

Measurement of Interacting Ethanol Droplets Evaporation at Moderately Elevated Temperature and Pressure Using Phase Rainbow Refractometry

Transient Effects and Mass Convection in Sessile Droplet Evaporation: the Role of Liquid and Substrate Thermophysical Properties

Experimental and Theoretical Investigation of Contact-Angle Variation for Water–ethanol Mixture Droplets on a Low-Surface-energy Solid

Numerical Simulation of Evaporation of Ethanol–Water Mixture Droplets on Isothermal and Heated Substrates

The Interaction Between Droplet Evaporation and Turbulence with Interface-Resolved Direct Numerical Simulation

Numerical study on the effects of experimental parameters on evaporation characteristic of a droplet

Numerical Study On Evolution Of Sessile Water Droplets During Evaporation

Evaporation of sessile droplet on surfaces with various wettability

Molecular Dynamics Study of Binary Nanodroplet Evaporation on a Heated Homogeneous Substrate

Evaporation of sessile ethanol-water droplets on a highly inclined heated surface

Theoretical Analysis of a Sessile Evaporating Droplet on a Curved Substrate with an Interfacial Cooling Effect

Experimental and Numerical Investigations on Flash Evaporation of a Sessile Droplet under Reduced Pressure

Droplet Evaporation to Boiling in Van Der Waals Fluid

Effect of liquid–vapor interface area on the evaporation rate of small sessile droplets

An analysis of flow characteristics during ethanol natural evaporation in capillary tubes with varying diameters

A Combined Computational and Experimental Investigation on Evaporation of a Sessile Water Droplet on a Heated Hydrophilic Substrate

Evaporation of ethanol-water sessile droplet of different compositions at an elevated substrate temperature

The Flow Characteristics of an Evaporating Ethanol Water Mixture Droplet on a Glass Substrate

Experimental Study on Evaporation Characteristics of Methyl Oleate Droplet Across Critical Pressure and Temperature Environments