Abstract:Biomass is regarded as CO2-neutral, while the high contents of potassium and chlorine in biomass induce severe particulate matter emission, ash deposition, and corrosion in combustion facilities. Co-firing biomass with coal in pulverized-combustion (PC) furnaces is able to solve these problems, as well as achieve a much higher generating efficiency than grate furnaces. In this work, the particulate matter (PM) emission from biomass co-firing with coal was studied in an entrained flow reactor at a temperature of 1623 K simulating PC furnace condition. PMs were sampled through a 13-stage impactor, and their morphology and elemental composition were characterized by scanning electron microscopy and electron dispersive X-ray spectroscopy. SO2 emissions were measured to interpret the possibility of potassium sulfation during co-firing. Results show that PMs from the separated combustion of both biomass and coal present a bimodal particle size distribution (PSD). The concentration and size of fine-mode submicron particles (PM1.0) from biomass combustion are much higher than those from coal combustion because of the high potassium content in biomass. For the co-firing cases, with the coal ratio increasing from 0% to 50%, the PM1.0 yield is reduced by more than half and the PM1.0 size becomes smaller, in contrast, the concentration of coarse-mode particles with the size of 1.0-10 mu m (PM1.0-10) increases. The measured PM1.0 yields of co-firing are lower than the theoretically weight-averaged ones, which proves that during the biomass and coal co-firing in PC furnaces, the vaporized potassium from biomass can be efficiently captured by these silicon-aluminate oxides in coal ash. In the studied range of coal co-firing ratio (<= 50 wt.%), the chlorides and sulfates of alkali metals from biomass burning are the dominating components in PM1.0, and a certain amount of silicon is observed in PM0.1-1. The analysis of chemical composition in PM1.0, together with that of SO2 emission, indicates a marginal sulfation of alkali metal chloride occurring at high temperatures in PC furnaces. (C) 2018 Energy Institute. Published by Elsevier Ltd. All rights reserved.

Experimental Study of the Influence of Synergistic Effects on the Co-Firing Characteristics of Biomass and Coal

Thermodynamics and synergistic effects on the co-combustion of coal and biomass blends

Experimental study on co-firing characteristics of coal/biomass blends in O2/CO2 atmosphere

Catalytic and Non-Catalytic Synergistic Effects and Their Individual Contributions to Improved Combustion Performance of Coal/biomass Blends

Synergistic effect and volatile emission characteristics during co-combustion of biomass and low-rank coal

Combustion Kinetic Behavior of Different Ash Contents Coals Co-Firing with Biomass and the Interaction Analysis

A DNS Study on Temporally Evolving Jet Flames of Pulverized Coal/biomass Co-Firing with Different Blending Ratios

Investigation on the Synergetic Effect of Biomass Co-Firing in the Atmosphere of O2/CO2

Synergistic Effect for Co-Coking of Sawdust and Coal Blending Based on the Chemical Structure Transformation

Experimental Study and Design of Biomass Co-Firing in a Full-Scale Coal-Fired Furnace with Storage Pulverizing System

Combustion and Heat Transfer Characteristics of Co-Firing Biomass and Coal under Oxy-Fuel Condition

Numerical Study of Co-firing Biomass with Lean Coal under Air–Fuel and Oxy-fuel Conditions in a Wall-Fired Utility Boiler

Co-Firing Behaviors and Kinetics of Different Coals and Biomass

Influence of the synergistic effects between coal and hemicellulose/cellulose/lignin on the co-combustion of coal and lignocellulosic biomass

Effect of fuel origin on synergy during co-gasification of biomass and coal in CO2

Numerical and Experimental Study on Oxy-fuel Coal and Biomass Co-firing in the Bubbling Fluidized Bed

Influence of Coal Co-Firing on the Particulate Matter Formation During Pulverized Biomass Combustion

Synergistic Effects on the Co-Combustion of Medicinal Biowastes with Coals of Different Ranks

Study on the Co-combustion Characteristics and Synergistic Effect of Semi-Coke and Dust Coal Produced from Biomass Briquette in Fluidized Bed Gasification

Comprehensive study on co-combustion behavior of pelletized coal-biomass mixtures in a concentrating photothermal reactor

Co-combustion of pulverized coal and walnut shells in air and oxy-fuel atmospheres: Thermal behavior, synergistic effect and kinetics