Abstract:The depletion of ore deposits, the increasing demand for raw materials, the need to process low-grade, complex and finely disseminated ores, and the reprocessing of tailings are challenges especially for froth flotation separation technologies. Even though they are capable of handling relatively fine grain sizes, the flotation separation of very fine and ultrafine particles faces many problems still. Further, the flotation of low-contrast semi-soluble salt-type minerals with very similar surface properties, many complex interactions between minerals, reagents and dissolved species often result in poor selectivity. This study investigates the flotation beneficiation of ultrafine magnesite rich in dolomite from desliming, currently reported to the tailings. The paper especially focuses on the impact of the depressant sodium hexametaphosphate (SHMP) on the following: (i) the froth properties using dynamic froth analysis (DFA), (ii) the separation between magnesite and dolomite/calcite, and (iii) its effect on the entrainment. As a depressant/dispersant, SHMP has a beneficial impact on the flotation separation between magnesite and dolomite. However, there is a trade-off between grade and recovery, and as well as the dewatering process which needs to be considered. When the SHMP increases from 200 g/t to 700 g/t, the magnesite grade increases from 67% to 77%, while recovery decreases massively, from 80% to 40%. The open circuit with four cleaning stages obtained a concentrate assaying 77.5% magnesite at a recovery of 45.5%. The dolomite content in the concentrate is about 20%, where 80% of dolomite was removed and importantly 98% of the quartz was removed, with only 0.3% of the quartz in the final concentrate. Furthermore, the application of 1-hydroxyethylene-1,1-diphosphonic acid (HEDP) as a more environmentally friendly and low-cost alternative to SHMP is presented and discussed. Using only 350 g/t of HEDP can achieve a similar grade (76.3%), like 700 g/t of SHMP (76.9%), while obtaining a 17% higher magnesite recovery as compared to 700 g/t of SHMP. Interestingly, the proportion of hydrophilic quartz minerals ending up in the concentrate is lower for HEDP, with only 1.9% quartz at a recovery of 21.5% compared to the 2.7% of quartz at a recovery of 24.9% when using SHMP. The paper contributes in general to understanding the complexity of the depressant responses in froth flotation.

Selective Depression of Phenoxyacetyl Chloride on Magnesite: Implications for Effective Flotation Separation of Magnesite from Dolomite

Original Data and Descriptions from Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Effect of Depressants on Flotation Separation of Magnesite from Dolomite and Calcite

Selective Flotation Separation of Magnesite from Dolomite and Calcite Using the Mixed WG + HEDP Depressants

The Enhanced Flotation Separation of Magnesite and Dolomite by Introducing Chelating Reagent EDTA

Flotation separation of magnesite and dolomite regulated by synergistic effect of acid etching and inhibitors

Flotation Separation of Magnesite from Dolomite Using Sodium Silicate Modified with Zinc Sulfate as a Selective Depressant

Experimental and simulation study on the flotation separation of smithsonite from dolomite using phosphoryl carboxyl copolymer as a novel depressant

Flotation separation of magnesite from dolomite with gellan gum as depressant and its depression mechanism

Selective depression by using environment-friendly depressant pectin in apatite and dolomite flotation system

Depressing effect of fine hydrophilic particles on magnesite reverse flotation

Study on regulators of purifying magnesite ore by cationic reverse flotation

Utilization of a novel bisphosphonic acid surfactant for reverse froth flotation of magnesite and dolomite

Selective inhibition of sodium tripolyphosphate on calcite in the process of magnesite flotation

Selection of an Appropriate Depressant in Flotation Separation of Molybdenum Oxide from Fluorapatite

Separation of Sphalerite and Dolomite Using Sodium Alginate As an Environmentally Friendly Depressant in a Carbonate-Hosted Pb-Zn Ore System

Efficient separation of magnesite and quartz using eco-friendly Dimethylaminopropyl lauramide experimental and mechanistic studies

Effect and Mechanism of Depressant CK102 on Flotation Separation of Fluorite and Dolomite

Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Impact of Sodium Hexametaphosphate on the Flotation of Ultrafine Magnesite from Dolomite-Rich Desliming Tailings

The interaction mechanism of a novel polymer depressant with apatite and dolomite surface and its implication on flotation: Experimental tests and DFT calculation