Abstract:The depletion of ore deposits, the increasing demand for raw materials, the need to process low-grade, complex and finely disseminated ores, and the reprocessing of tailings are challenges especially for froth flotation separation technologies. Even though they are capable of handling relatively fine grain sizes, the flotation separation of very fine and ultrafine particles faces many problems still. Further, the flotation of low-contrast semi-soluble salt-type minerals with very similar surface properties, many complex interactions between minerals, reagents and dissolved species often result in poor selectivity. This study investigates the flotation beneficiation of ultrafine magnesite rich in dolomite from desliming, currently reported to the tailings. The paper especially focuses on the impact of the depressant sodium hexametaphosphate (SHMP) on the following: (i) the froth properties using dynamic froth analysis (DFA), (ii) the separation between magnesite and dolomite/calcite, and (iii) its effect on the entrainment. As a depressant/dispersant, SHMP has a beneficial impact on the flotation separation between magnesite and dolomite. However, there is a trade-off between grade and recovery, and as well as the dewatering process which needs to be considered. When the SHMP increases from 200 g/t to 700 g/t, the magnesite grade increases from 67% to 77%, while recovery decreases massively, from 80% to 40%. The open circuit with four cleaning stages obtained a concentrate assaying 77.5% magnesite at a recovery of 45.5%. The dolomite content in the concentrate is about 20%, where 80% of dolomite was removed and importantly 98% of the quartz was removed, with only 0.3% of the quartz in the final concentrate. Furthermore, the application of 1-hydroxyethylene-1,1-diphosphonic acid (HEDP) as a more environmentally friendly and low-cost alternative to SHMP is presented and discussed. Using only 350 g/t of HEDP can achieve a similar grade (76.3%), like 700 g/t of SHMP (76.9%), while obtaining a 17% higher magnesite recovery as compared to 700 g/t of SHMP. Interestingly, the proportion of hydrophilic quartz minerals ending up in the concentrate is lower for HEDP, with only 1.9% quartz at a recovery of 21.5% compared to the 2.7% of quartz at a recovery of 24.9% when using SHMP. The paper contributes in general to understanding the complexity of the depressant responses in froth flotation.

Flotation separation of magnesite from dolomite with gellan gum as depressant and its depression mechanism

The role of gellan gum in the selective flotation separation of fluorite from calcite: An experimental and molecular dynamics simulation study

Effective Flotation Separation of Chalcopyrite and Graphite Using Eco-Friendly Xanthan Gum As Depressant

Flotation Separation of Magnesite from Dolomite Using Sodium Silicate Modified with Zinc Sulfate as a Selective Depressant

Exploring Dextrin As an Eco-Friendly Depressant for Selective Flotation Separation of Scheelite and Calcite Minerals

Flotation separation of magnesite and dolomite regulated by synergistic effect of acid etching and inhibitors

Effect of Zn<SUP>2+</SUP> and its addition sequence on flotation separation of scheelite from calcite using water glass

Effect and Mechanism of Depressant CK102 on Flotation Separation of Fluorite and Dolomite

The utilization of tamarind seed gum as a novel dolomite depressant in the selective flotation of apatite from dolomite

Flaxseed gum as new depressant in the separation of apatite and dolomite and its mechanism

Utilization of a novel bisphosphonic acid surfactant for reverse froth flotation of magnesite and dolomite

Depressing effect of fine hydrophilic particles on magnesite reverse flotation

Exploration of a novel depressant pullulan gum for the flotation separation of specularite from aegirite

Study on regulators of purifying magnesite ore by cationic reverse flotation

Enhanced flotation of magnesite and dolomite in sodium oleate system using eco-friendly dodecyl dimethyl betaine

Exploration of disodium methylenebis naphthalene sulfonatea as a novel depressant for the flotation separation of apatite from dolomite

Experimental and simulation study on the flotation separation of smithsonite from dolomite using phosphoryl carboxyl copolymer as a novel depressant

Selective inhibition of sodium tripolyphosphate on calcite in the process of magnesite flotation

Impact of Sodium Hexametaphosphate on the Flotation of Ultrafine Magnesite from Dolomite-Rich Desliming Tailings

Flotation separation of molybdenite from talc using carrageenan as depressant

Flotation separation of chalcopyrite from galena using locust bean gum as a selective and eco-friendly depressant