Low-Side-Extended-Phase-Shift-Under-Resonant Modulation Scheme for Dual-Bridge-Series-Resonant Converter

Yihan Gao,Lu Zhou,Zihang Zhou,Qiang Ding,Xin Zhang,Hao Ma

DOI: https://doi.org/10.1109/tie.2024.3374395

IF: 7.7

2024-01-01

IEEE Transactions on Industrial Electronics

Abstract:This article proposes a low-side-extended-phase-shift-under-resonant modulation (LS-EPSURM) scheme for the dual-bridge-series-resonant converter (DBSRC), which is characterized by the introduction of an inner-phase-shift angle on the relatively low-voltage side while operating at the under-resonant mode. Compared with the extended-phase-shift-over-resonant modulation (EPSORM) scheme, the proposed LS-EPSURM scheme can effectively extend the soft-switching range of the circuit, while the required frequency range can be reduced instead. Moreover, this article investigates and identifies the optimal selection of control variables to reduce the backflow current and inductor root-mean-square current while achieving full-range zero voltage switching operation, thereby further improving the transmission efficiency of the circuit in the whole load range. The developed approach is validated on a 10.2 kW/L 2kW DBSRC prototype with output voltage varying from 250 to 500 V, the switching frequency range is 325-450 kHz, and the peak efficiency is 97.5%.