Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Density and Viscosity Measurement of R513A and a Modified Residual Entropy Scaling Model for Predicting the Viscosity of HFC/HFO Refrigerants

Investigation on Liquid Density Data at the Bubble Point and Equations for the Refrigerant Hfc-404a over A Wide Temperature Range

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Vapor–liquid Equilibria of HFC‐161 + HFC‐32 + DMF Ternary Mixture for Low‐grade Heat Driven Absorption Refrigeration System

Measurements of Gas Phase Pvtx Properties for the Ternary Hfc-161/125/32 System

Isothermal Vapor–Liquid Equilibrium of HFC-161 + DMETrEG Within the Temperature Range of 293.15–353.15 K and Comparison for HFC-161 Combined with Different Absorbents

Measurement of Saturated Vapor Pressure and Compressed Liquid Density for 1,1,1,3,3,3-Hexafluoroisopropylmethyl Ether

An Experimental Study of PVTx Properties in the Gas Phase for Binary Mixtures of HFC-161 and HFC-32

Isothermal Vapor–Liquid Equilibrium of the Ternary Mixture of 1,1,1,2-Tetrafluoroethane + 2,3,3,3-Tetrafluoroprop-1-ene + Dimethyl Ether at Temperatures from 253.15 K to 323.15 K

Investigating the Thermal-Hydraulic Performance of New Refrigerant Mixtures Through Numerical Simulation of Minichannel and Microchannel Evaporators

Development and Stability Verification of a Measuring Installation of Saturation Liquid Density

Modeling thermal conductivity of liquid hydrofluorocarbon, hydrofluoroolefin and hydrochlorofluoroolefin refrigerants

Vapor-liquid Equilibrium Measurement and Heating Performance Modeling on Eco-Friendly Zeotropic Blends of CO2/R1234ze(Z) and CO2/R1336mzz(E)

Modeling the Viscosity of Hydrofluorocarbons, Hydrofluoroolefins and Their Binary Mixtures Using Residual Entropy Scaling and Cubic-Plus-association Equation of State

Experimental and Theoretical Research on the Saturated Liquid Thermal Conductivity of HFO-1336mzz(E)

Vapor−Liquid Equilibrium Data for the Binary Mixture Difluoroethane (HFC-32) + Pentafluoroethane (HFC-125) of an Alternative Refrigerant

Dynamic Viscosity for HFC-134a + Polyether Mixtures up to 373.15 K and 140 MPa at Low Polyether Concentration. Measurements and Modeling

Viscosity of Binary Refrigerant Mixtures of R32+R1234yf and R32+R1243zf

Isothermal vapor–liquid equilibrium data for the binary mixture ethyl fluoride (HFC-161) + 1,1,1,2,3,3,3-heptafluoroproane (HFC-227ea) over a temperature range from 253.15 K to 313.15 K

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Modeling of compressed liquid viscosity of hydrofluorocarbons, hydrofluoroolefins, hydrochlorofluoroolefins, hydrochlorofluorocarbons and their mixtures