Abstract:A cleaner and atomic economy production of hydroxylamine hydrochloride (NH2OH·HCl) under solvent-free conditions through process intensification is developed to solve the mutual problems of solvent hazard and complicated process in traditional methods. The hydrogen peroxide (H2O2), ammonia (NH3) and 2-butanone achieved ammoximation successfully via Ti-MWW in the membrane reaction unit. 2-butanone oxime after dehydration and deamination was hydrolyzed with hydrochloric acid (HCl) in the reaction distillation unit to produce NH2OH·HCl. The catalyst, NH3 and 2-butanone were separated and recycled, respectively. Under optimized conditions, the process showed high the conversion of 2-butanone (97%), selectivity of 2-butanone oxime (100%), yield of NH2OH·HCl (91.6%) and recovery rate of 2-butanone (85.1%). Recycling of materials achieved atomic economy, coupling enhancement of membrane reaction unit, deamination unit and reactive distillation unit achieved high-efficiency continuous process. The whole process ran stably by using Aspen Plus v10 for simulation, the content of H2O2 in the membrane reaction outlet and content of NH3 in the deamination bottom optimized by simulation could meet the requirements of industrialization. The analysis of techno-economic and environment showed that the progress only produced a small amount of waste water which could treat with activated sludge aeration method. The process had low material cost, less environmental impact and high equipment utilization. Therefore, this work can guide manufacturers for the cleaner production of NH2OH·HCl and also provide valuable information for improvement of similar processes and production of similar products.

H&lt;sub&gt;2&lt;/sub&gt;O&lt;sub&gt;2&lt;/sub&gt; Production Technology with Slurry Reactor

Advances in the slurry reactor technology of the anthraquinone process for H 2 O 2 production

Technology Progress of P-Xylene Oxidation Reactor

Chemical and engineering bases for green H2O2 production and related oxidation and ammoximation of olefins and analogues

Process intensification of reactive extraction for hydrogen peroxide production in a rotating packed bed reactor

Research Progress in Reaction Mechanism and Working Solution for Hydrogen Peroxide Production by Anthraquinone Process

Sludge Treatment by O-3/H2o2 and Carbon Source Recovery

Optimization and reforming for hydrogen peroxide production unit by anthraquinone method

Experimental investigation and simulation of gas–liquid–liquid reactive extraction process for the production of hydrogen peroxide

Advances in hydrogenation catalyst for the production of hydrogen peroxide through the anthroquinone route

Direct Thermal Catalytic Synthesis of Hydrogen Peroxide by Using Microchip Reactor

GAS-AGITATED LIQUID AND OXIDATIVE EXTRACTION IN THE ALKYL ANTHRAQUINONE PROCESS FOR THE PREPARATION OF HYDROGEN PEROXIDE

Photocatalytic Production of H2O2 and Its In-Situ Environmental Applications

FORMATION OF HYDROGEN PEROXIDE IN DBD NON-THERMAL REACTOR WITH WATER MIST

Production of Hydrogen Peroxide by Photocatalytic Processes

Progress of Study on Hydrogen Production by Reformings of Hydrocarbons and Alcohols

Study on improvement of sludge dewaterability with H<sub>2</sub>O<sub>2</sub> cell lysis

Novel Working Solvent for the Production of Hydrogen Peroxide

Cleaner and atomic economy production of hydroxylamine hydrochloride under solvent-free conditions through process intensification

Advances in Production of Hydrogen from Sludge

Recent Advances in Tailoring the Microenvironment of Pd-based Catalysts for Enhancing the Performance in the Direct Synthesis of Hydrogen Peroxide.

H&amp;lt;sub&amp;gt;2&amp;lt;/sub&amp;gt;O&amp;lt;sub&amp;gt;2&amp;lt;/sub&amp;gt; Production Technology with Slurry Reactor