Abstract:This paper presents a high-performance liquid chromatography-UV detection analytical method for the determination of tris(2,4-di-tert-butylphenyl)phosphite(TBP) and its poisonous impurity (2,4-di-)tert-(butylphenol)(DBP). The separation between TBP and DBP was performed on a Kromasil C_(18) column, 5 μm, 150 mm×4.6 mm(i.d.), and the quantitation was achieved with UV detection at 275 nm. The (column) temperature was maintained at 30 ℃. The mobile phase was a mixture of methanol and water and run at a flow rate of 1.0 mL/min, and a two-step linear gradient elution, 0～5 min, V(methanol)∶V(water)=(95∶5); 5～25 min, V(methanol)∶V(water)=100∶0, was adopted. The calibration curves were (linear) in the concentration ranges of 1.0×10~(-6)～1.0×10~(-3) g/mL of TBP and 1.0×10~(-7)～1.0×10~(-4) g/mL of DBP, respec-(tively), with correlation coefficients of 0.999 94 and 0.999 95. The detection limits were 1.0×10~(-7) g/mL for TBP and 1.0×10~(-8) g/mL for DBP. Good reproducibility was obtained for the determinations of TBP and DBP in real industrial samples with relative standard deviations of 0.1% and 1.8%, respectively. The DBP (analysis) result obtained by HPLC were compared with that by spectrophotometry, and it was found that the (spectrometric) method was (unable) to determine DBP in TBP accurately. Two impurities were identified by (LC-MS). The structure of another impurity was estimated according to its UV-Vis spectrum and chromatographic behavior. All these three impurities in antioxidant 168 were TBP derivatives with fewer tert-butyl substituents. When an isocratic elution was used:((0～)20 min, (V(methanol)∶)V(water)=100∶0), this method was applied to analyze TBP in composite antioxidants with a relative standard deviation of 0.7% and a recovery rate of 101%.

Purification and Purity Determination of 2,6-Di-tert-butyl-p-cresol

Separation of Catalpol from Rehmannia Glutinosa Libosch by High-Speed Countercurrent Chromatography

Purification of d-a-tocopheryl polyethylene glycol 1000 succinate (TPGS) by a temperature-modulated silica gel column chromatography: use of Taguchi method to optimize purification conditions.

Separation And Purification Of Beta-Carotene From Chlorophyll Factory Residues

Purity Determination of 1,3-Bis(2-hydroxyethoxy)benzene by Differential Scanning Calorimetry

Separation and Purification of Desmosterol by Simulated Moving Bed Chromatography

Purification of Amygdalin

Preparation of 2-t-Butyl-p-cresol Catalyzed by Hβ Zeolite

Extraction and Purification of 10-Deacetyl Baccatin Ⅲ from Taxus Mairei

Simultaneous Chemical Fingerprinting and Quantitative Analysis of Crude and Processed Radix Scrophulariae from Different Locations in China by HPLC.

Quality Control Method for Tris(2,4-di-tert-butylphenyl) Phosphite Production and Identification of Its Impurities

High Purity m-Cresol Obtained by Combination of Urea and Calcium Bromide Method

Isolation and Purification of Two Constitutes from Dendrobium Fimbriatum Hook by High-Speed Counter-Current Chromatography Using Stepwise Elution

Preparation of High Purity Reagents of Chlorobutanol by Sublimation Purification Method

Purification and characterization of 4-tert-butyl-4-methoxy-dibenzoylmethane

Purification of Hyodeoxycholic Acid and Chenodeoxycholic Acid from Pig Bile Saponification Solution Using Column Chromatography

Direct Purification of Tanshinones from Salvia Miltiorrhiza Bunge by High-Speed Counter-Current Chromatography Without Presaturation of the Two-Phase Solvent Mixture

Ethylene Glycol Purification by Melt Crystallization: Removal of Short-Chain Glycol Impurities

Purification of 2-Chloro-4,6-dinitroresorcinol by Antisolvent Crystallization Method

PURIFICATION FOR DIHYDROMYRICETIN BY HIGH-SPEED COUNTERCURRENT CHROMATOGRAPHY(HSCCC)

Determination of 2,6-Di-tert-butyl-hydroxytoluene and Its Transformation Products in Indoor Dust and Sediment by Gas Chromatography-Mass Spectrometry Coupled with Precolumn Derivatization