Abstract:In this paper, the flotation separation of quartz and feldspar was studied with CaCl 2 as activators and mixed sodium oleate/ dodecylamine (NaOL/DDA) collectors under alkaline condition, and the action mechanism of mixed NaOL/DDA collectors on the quartz and feldspar surfaces were systematically explored. The results of micro-flotation test showed that there were 90.98% quartz and 13.08% feldspar were floated with 0.5 mmol/L CaCl 2 and 2.8 mmol/L mixed NaOL/DDA collectors with molar ratio of 8/1 at pH 10.0. And the artificial mixed minerals flotation manifested these two minerals were able to efficient separation with CaCl 2 and mixed NaOL/DDA collectors at pH 10 ∼ 11. These outcomes indicated that DDA could increase recovery of quartz obviously and reduce about a half dosage of NaOL (from 0.5 mmol/L to 0.25 mmol/L) in flotation under alkaline condition; Meanwhile, mixed NaOL/DDA collectors were able to decreased the flotation separation pH from 12 to 10 on quartz and feldspar. Infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS) results revealed that when NaOL collector was added alone, it could adsorb on activated quartz surface but hardly detected on feldspar surface at pH 10. However, they all were found on both quartz and felspar surface when mixed NaOL/DDA collectors were introduced as collectors. Quartz microcrystal balance with dissipation (QCM-D) experiment confirmed that mixed NaOL/DDA collectors showed a higher adsorption mass and more stable adsorption layer on quartz compared with NaOL was introduced as collector alone. In addition, whether CaCl 2 , NaOL or mixed NaOL/DDA, the adsorption mass on quartz sensor were larger than that on feldspar senor, which might cause difference of hydrophobicity on the surface of quartz and feldspar in flotation. The above experiments showed that the mixed NaOL/DDA collectors can significantly improve hydrophobic difference between quartz and feldspar after activating with CaCl 2 and expand the floated pH range of quartz compared with using NaOL as collector alone, which were efficient reagents to separate quartz and feldspar in flotation.

Selective Flotation Separation of Spodumene from Feldspar Using New Mixed Anionic/cationic Collectors

Selective flotation separation of spodumene from feldspar using a novel mixed anionic/cationic collector NaOL/ND13

Adsorption Mechanism of New Mixed Anionic/cationic Collectors in a Spodumene-Feldspar Flotation System

The selective adsorption and flotation separation of spodumene from feldspar using a novel iron-group multiple ligand collector

In Situ Adsorption of Mixed Anionic/Cationic Collectors in a Spodumene-Feldspar Flotation System: Implications for Collector Design

Selective Flotation Separation of Fluorite from Calcite Using Mixed Anionic/cationic Collectors

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Flotation of Li Pegmatite with a Soybean Oil-Based Collector: Fundamental Studies

Dodecylphosphonic acid for the separation of spodumene and albite: Flotation behavior and adsorption mechanism

A self-assembly mixed collector system and the mechanism for the flotation separation of spodumene from feldspar and quartz

Enhanced flotation separation of spodumene and albite via selective adsorption of N -hydroxy-9-octadecenamide on the mineral surfaces

The synergetic collecting effect of N-oleoyl sarcosine (N-OSS) and dodecylamine (DDA) on the selective flotation of spodumene from albite

A novel combined collector with superior selectivity for flotation separation of lepidolite from feldspar: Experimental insight and MD simulation

Flotation behavior and mechanism of α-bromododecanoic acid as collector on the flotation separation of spodumene from feldspar and quartz

Selective flotation of scheelite from calcite using a novel self-assembled collector

Microscale insights into the influence of grinding media on spodumene micro-flotation using mixed anionic/cationic collectors

Method and mechanism of reverse flotation for dephosphorization of spodumene concentrate using sodium alginate as a depressant

Adsorption mechanisms of activated surface of quartz and feldspar with mixed NaOL/DDA

Study on the flotation separation mechanism of diaspore from kaolinite using mixed NaOL/BHA collector

The selective flotation separation of apatite from dolomite and calcite utilizing a combination of 2-chloro-9-octadecenoic acid collector and sodium pyrophosphate depressant

Reverse flotation of ultrafine magnetic concentrate by using mixed anionic/cationic collectors