Abstract:The effects of Ca(II), Mg(II), Cu(II), and Fe(III) on the flotation separation of spodumene from feldspar and quartz were investigated by single-mineral and artificial-mixed-ore flotation experiments using α-bromododecanoic acid (α-BDDA) as a collector. At pH≈7, Ca(II), Mg(II), and Cu(II) selectively improved the flotation of spodumene, which facilitated the separation of spodumene. Although Fe(III) exhibited strong activation ability, its selectivity toward spodumene was low, which impaired the separation of spodumene. Moreover, the sequence of addition of metal ions had an impact on the separation of spodumene. When Ca(II) and Mg(II) were used as activators in the artificial-mixed-ore flotation experiments, concentrates with recoveries of 75.6% and 76.3% and Li2O grades of 5.8% and 5.2% were obtained, respectively. Adsorption and activation mechanisms of metal ions were analyzed by adsorption amount measurements, Fourier transform infrared spectroscopy, species distribution calculation, and frontier orbital theory calculation. Results indicated that the amount of α-BDDA adsorbed on spodumene was higher than those adsorbed on feldspar and quartz when Ca(II), Mg(II), and Cu(II) were employed as activators, which led to a higher recovery of spodumene. When the pH was approximately 7, Ca(II), Mg(II), Fe(III), and Cu(II) were mainly present as Ca2+, Mg2+, Fe(OH)3 and Fe(OH)2+, and Cu(OH)2, Cu2+, and Cu(OH)+, respectively. The results of frontier orbital theory calculations demonstrated that α-BBBA, Ca2+, and Mg2+ easily adsorbed on spodumene than on feldspar and quartz. Therefore, Ca(II) and Mg(II) facilitated the separation of spodumene. However, Fe(OH)2+ preferentially reacted with spodumene, whereas Fe(OH)3 preferably reacted with feldspar and quartz, which caused low selectivity of Fe(III) toward spodumene. Similarly, Cu2+ and Cu(OH)+ easily adsorbed on spodumene, whereas Cu(OH)2 preferentially adsorbed on feldspar and quartz. Thus, the selectivity of Cu(II) toward spodumene was inferior compared to those of Ca(II) and Mg(II).

Microscale insights into the influence of grinding media on spodumene micro-flotation using mixed anionic/cationic collectors

Effect of Grinding Media on the Flotation Behavior of Fluorite Using Sodium Oleate As a Collector

In Situ Adsorption of Mixed Anionic/Cationic Collectors in a Spodumene-Feldspar Flotation System: Implications for Collector Design

Adsorption Mechanism of New Mixed Anionic/cationic Collectors in a Spodumene-Feldspar Flotation System

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Selective flotation separation of spodumene from feldspar using a novel mixed anionic/cationic collector NaOL/ND13

The relationship between spodumene surface pretreatment and flotation behavior: A review

The selective adsorption and flotation separation of spodumene from feldspar using a novel iron-group multiple ligand collector

Mechanism of Fe(III)-modified silicate in the flotation separation of spodumene and albite: An experimental and theoretical study

A self-assembly mixed collector system and the mechanism for the flotation separation of spodumene from feldspar and quartz

Effects of grinding media on the flotation performance of cassiterite

The synergetic collecting effect of N-oleoyl sarcosine (N-OSS) and dodecylamine (DDA) on the selective flotation of spodumene from albite

Enhanced flotation of chalcopyrite particles by grinding with short cylinder media

Flotation of Li Pegmatite with a Soybean Oil-Based Collector: Fundamental Studies

Method and mechanism of reverse flotation for dephosphorization of spodumene concentrate using sodium alginate as a depressant

Effects of metal ions on the flotation separation of spodumene from feldspar and quartz

Effects of Grinding Media on Grinding Products and Flotation Performance of Sulfide Ores

Flotation behavior and mechanism of α-bromododecanoic acid as collector on the flotation separation of spodumene from feldspar and quartz

Adsorption mechanisms of activated surface of quartz and feldspar with mixed NaOL/DDA

The evaluation of N-OSS (N-oleoyl sarcosine) as an efficient collector in the flotation of spodumene from albite at low temperature: Experimental tests and atom-level calculation

The flotation behavior and adsorption mechanism of a new cationic collector on the separation of spodumene from feldspar and quartz