Abstract:Driven by frequency conversion, the windings of a three-phase permanent magnet synchronous motor (PMSM) contain both odd and even harmonic currents. Due to the motor's pole–slot conductance modulation, the interaction between the magnetic fields generated by these harmonic currents and the permanent magnet field results in harmonic radial vibrations of the motor. This paper analyzes the three-phase currents of the prototype and derives the radial magnetomotive force (MMF) spatiotemporal models for symmetric harmonic currents. By integrating Maxwell's magnetic force formula and vibration response formula, the radial vibration models for symmetric harmonic currents are developed. The characteristics of vibrations caused by odd and even harmonic currents, as well as positive sequence and negative sequence harmonic currents, are analyzed separately. A cyclic sequence, low-frequency vibration suppression control method incorporating multiple harmonic current injections was designed. Experimental results of this method are compared with those obtained using an ideal sinusoidal current. Except for the second harmonic vibration, all other vibrations are significantly suppressed, with a maximum suppression rate of 92.28%. The total vibration level is reduced by 12.7619 dB, and the average torque is reduced by 0.67% with the total harmonic distortion of the current at 2.89%. The experimental results show that the vibration method in this paper has little influence on the average torque of the motor, the current distortion rate is small, and the vibration suppression effect is good.

Vibration Suppression for PMSM Flexible Servo Systems Using Enhanced Two-Mode Shapers

A Fast Integral Sliding Mode Controller with an Extended State Observer for Position Control of Permanent Magnet Synchronous Motor Servo Systems

A Vibration Mitigation Approach for Inverter-fed Permanent Magnet Motor Drive System

Zeroth-Mode Vibration Suppression through Adjustment on Phases Difference of Concentrated Force Harmonics for PMSMs

Combining Input Shaping and Adaptive Model-Following Control for Vibration Suppression

Zeroth-Mode Vibration Suppression for Surface-Mounted PMSM by Increasing the Axial Spatial Order of Electromagnetic Force

The Mechanism for Suppressing High-Frequency Vibration of Multiphase Surface Permanent Magnet Motors via PWM Carrier Phase Shifting

Mechanical Resonance Suppressing Method For Pmsm System Based On High-Order Sliding Modes

A Review on Disturbance Analysis and Suppression for Permanent Magnet Linear Synchronous Motor

Research on Radial Vibration Model and Low-Frequency Vibration Suppression Method in PMSM by Injecting Multiple Symmetric Harmonic Currents

An Optimal Periodic Carrier Frequency PWM Scheme for Suppressing High-Frequency Vibrations of Permanent Magnet Synchronous Motors

Zeroth-Mode Vibration Suppression for Integral-Slot Surface-Mounted PMSMs by Increasing the Vibration Mode from Zero to Number of Pole Pair

Active Vibration Suppression of a 3-DOF Flexible Parallel Manipulator Using Efficient Modal Control

Flexible Spacecraft Vibration Suppression Using Pwpf Modulated Input Component Command And Sliding Mode Control

Hybrid Pd and Effective Multi-Mode Positive Position Feedback Control for Slewing and Vibration Suppression of A Smart Flexible Manipulator

Four-Module Three-Phase PMSM Drive for Suppressing Vibration and Common-Mode Current

Modeling and Suppression of Torque Ripple in PMSM Based on the General Airgap Field Modulation Theory

Modeling, Design Optimization, and Verifications of Permanent Magnet Linear Actuators for Structural Vibration Mitigation Applications

Study of Electromagnetic Vibration Suppression for Permanent Magnet Synchronous Motors

Modeling and Active Vibration Control of an Intelligent Flexible Manipulator System

The Effects and Mechanisms of Periodic-Carrier-Frequency PWM on Vibrations of Multiphase Permanent Magnet Synchronous Motors